{"count":49,"message":"Results returned successfully","results":[{"odiNumber":11754798,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/05/2025","dateComplaintFiled":"08/04/2026","vin":"5ZT3CTYB7M1","components":"STRUCTURE","summary":"I am the original owner of a 2021 Forest River Wolf Pack 325PACK13 fifth-wheel trailer (VIN: [XXX]), purchased new on [XXX]. The trailer is built on a Lippert Components chassis manufactured in September 2020.  My trailer developed multiple structural cracks in the front overhang/pin box area of the frame. This is not a single crack. The damage includes multiple cracks in the steel chassis, separation between the fiberglass front cap and the trailer body, gaps between structural members beneath the floor, and movement throughout the front of the trailer.  Because the pin box transfers all towing forces into the frame, I considered the trailer unsafe to tow and immediately removed it from service. This is a structural failure involving the primary load-bearing chassis, not cosmetic damage. I am concerned this defect could affect towing stability, structural integrity, and increase the risk of failure during highway travel.  The trailer has remained at an authorized repair facility for approximately four months awaiting repairs. During that time, I have repeatedly contacted Forest River for updates, often daily, but have received virtually no meaningful communication. My calls have routinely gone unanswered or unreturned, and the repair facility has also struggled to obtain responses, significantly delaying repairs.  I am concerned this may represent a broader safety issue affecting other Forest River trailers built on similar Lippert chassis. I respectfully request that NHTSA investigate whether these structural frame failures are occurring in other units and determine whether a safety-related defect exists that warrants corrective action.  I have photographs documenting the multiple frame cracks, structural separation, repair records, warranty documentation, and communication records and will provide them upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11731816,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/10/2026","dateComplaintFiled":"04/17/2026","vin":"5ZT2CKFC5MY","components":"TIRES","summary":"Tire exploded during highway use creating a hazard to everyone near by. This is the second time this brand exploded on this trailer, same brand, same tire, different batches. There also also hundreds of complaints online on these tires. Pressure was checked that same morning and was not used above 75mph","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"CASTLE ROCK ST","size":"ST235/80R16","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11726947,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/11/2024","dateComplaintFiled":"03/25/2026","vin":"5ZT2CKRB0M2","components":"TIRES","summary":"Tire size was ST 205 / 75 R 15.  This tire experienced a significant belt separation failure that I fortunately noticed before departing our campsite. While doing a walk around inspection before departure, I noticed a severe tread deformity in the front passenger side tire on our camper. The tires were cold and the ambient air temperature was in the low 60's.  Before removing the tire and wheel from the trailer, I checked the tire pressure on all 4 tires,  and all were within 2 psi of the recommended 65 psi cold pressure, including the failing tire. I removed the wheel and tire assembly and deflated it for safety, and then took it to a local tires shop to replace the tire. They diagnosed it as belt separation and further stated that it would have likely failed with a blowout within a few miles if I hadn't caught it.  The tire had an estimated 15,000 miles on it at the time, but had been professionally repaired for a screw puncture approximately 7,000 miles earlier.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"GOODYEAR","productModel":"ENDURANCE","size":"ST205/7515D","manufacturer":"Goodyear Tire & Rubber Company"}]},{"odiNumber":11685770,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/31/2025","dateComplaintFiled":"09/08/2025","vin":"5ZT3CTXB4M1","components":"STRUCTURE,TRAILER HITCHES","summary":"The contact owns a 2021 Forest River Cherokee Toy Hauler. The contact stated that while driving at various speeds, the frame was flexing at the RV pin box location. The contact stated that while unhitching the trailer, the contact noticed that there was weld separation on the left and right sides of the tow hitch outer frame. Additionally, the contact stated that the cargo door holding the propane tank was opening unintendedly while driving. The trailer was taken to an independent mechanic, where it was diagnosed with spring damage, and the contact was informed that the cargo door that held the propane tank was opening unintendedly because the frame was flexing at the RV pin box location. The Lippert manufacturer that installed the frame was contacted and advised the contact to send pictures of the failure. The manufacturer, Forest River, was notified of the failure and advised the contact to apply gel in the weld gaps. The trailer was not repaired. The failure mileage was unknown.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11673588,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/14/2025","dateComplaintFiled":"07/15/2025","vin":"4X4TCKE29MX","components":"TIRES","summary":"ST 225/75R15 One driver side tire blew in May/2025 which caused extensive damage to the RV floor and sidewall. I replaced and did not file a claim. My family was in the tow vehicle when the blowout occurred. Debris was thrown across the highway and I had no room on the side of the highway to change the tire. Police called.  Yesterday July 14/2025, the spare tire blew up all on its own while at a campground. It was on the back of the camper not being used. The spare tire cover was destroyed. Neighbors thought a propane tank exploded. Anybody walking by could have been seriously injured. I did a search and found a recall for these tires.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"LIONSHEAD","productModel":"CASTLE ROCK","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11671277,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/01/2025","dateComplaintFiled":"07/04/2025","vin":"5ZT2CKRBXM2","components":"TIRES","summary":"Had for approximately 3 years. Spare tire never on ground but suddenly bulging.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"UNKNOWN","productModel":"UNKNOWN","size":null,"manufacturer":"UNKNOWN MANUFACTURER"}]},{"odiNumber":11671234,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/21/2025","dateComplaintFiled":"07/04/2025","vin":"4X4TCBK2XMK","components":"SUSPENSION,WHEELS,UNKNOWN OR OTHER","summary":"When I bought this camper I paid extra for an extensive warranty including the tires. On a recent trip I blew a tire on the trailer and contacted the warranty company. Was instructed to take the trailer and tire to an authorized service center. Upon doing so the service center notified me that the axles were bent because they were insufficient for the size of the trailer. The gentleman I spoke with said that regardless of what the tags read on the camper the axles were not sufficient for the load rating listed on the tag inside the camper. Thus they put excessive strain on the tires and one blew while I was traveling on the highway. He told me another one was ready to blow out. I reached out to the RV dealership where I bought the trailer and they referred me to the trailer manufacturer who denied any responsibility and claimed that the axles were sufficient for that trailer. This is a recurring issue with these travel trailers as I have friends who have the same models and one has already had to replace his axles because they bent and a tire blew out and damaged the side of his camper and the other one changed his tires and springs to help offset the weight issue. I even reached out to the axle manufacturer who supplied these components to the RV company and all they provided was this measurements I needed to order new axles. All I wanted from the RV manufacturer was even a pittance of an offer to help me with this issue but all they did was claim that all the parts were good and they weren't responsible. I have ordered new heavier duty axles and larger tires to accommodate the weight. As I stated the RV repair center that is working on my trailer said the axles were insufficient and the tires were actually too small for a trailer that size. Apparently the only way an RV company will do the right thing is if they are threatened with a lawsuit. Forest River has already been implicated in a  lawsuit for other issues. So they are aware that they have issues!","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11660482,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/11/2025","dateComplaintFiled":"05/12/2025","vin":"5ZT3CKUB6M0","components":"TIRES","summary":"Camped all weekend, and started to return home.  Merged onto highway 10 miles from campground, and 2.5 miles onto the highway at 65 mph, passenger side front tire blew the tread off and split tire from bead to bead perpendicular to tread.  Tires were at 80psi before trip. ST225/75r15","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST226","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11660484,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/11/2025","dateComplaintFiled":"05/12/2025","vin":"5ZT3CKUB6M0","components":"TIRES","summary":"Camped all weekend, and started to return home.  Drove half an hour from changing the last tire and lost the driver side front. Traveling 65 mph on the highway it blew and split the tire from bead to bead perpendicular to tread.  Tires were at 80psi before trip. ST225/75r15","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST226","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11656771,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/01/2024","dateComplaintFiled":"04/25/2025","vin":"5ZT2CKFC1MY","components":"STRUCTURE","summary":"The slide mechanism and gear rack are out of spec per their manufacturer of the component (schwintek inverted gear rack). On my unit the \u201cshoe\u201d part of the rack has failed (possibly because of improper installation) and I am afraid that if the slide is not secured by the gear rack that it could slip out while the vehicle is in motion. Lippert does have a TSB for this, but apparently doesn\u2019t apply to my date range. Lippert TSB is 146-001-2022.  Forest river tells me \u201cthis can happen over time from usage.\u201d  Lippert (schwintek mfg) says: \u201cThe concern appears to stem from an out-of-spec installation. We recommend reaching out to the coach manufacturer, as they may participate in resolving the issue\u201d  Neither company appear to be concerned for safety","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11645805,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/02/2025","dateComplaintFiled":"03/02/2025","vin":"5ZT2CKECXMY","components":"TIRES","summary":"We heard a loud bang and found the spare tire attached to the back of the trailer had exploded.  Trailer was not in use, stored in the side of the house.   ST205/75R14","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST22","size":"205/75/R14","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11615018,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/02/2024","dateComplaintFiled":"09/17/2024","vin":"5ZT2CKRB4M2","components":"STRUCTURE","summary":"Front entry door opens while driving down the road. I have started deadbolt locking it. Lucky the hand rail folded in has caught the door from swinging out. Still could be dangerous for other drivers if something inside falls out of the RV.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11613030,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/15/2024","dateComplaintFiled":"09/06/2024","vin":"5ZT2CKFC4MY","components":"TIRES","summary":"Castle Rock ST225/75r15  Was traveling with a 2021 Forest River RV and had a rapid loss of tire pressure and complete tread separation. Tires were at the proper pressure and driving below the speed rating of 70 mph. Incident occurred about an hour into trip, but less than 15 minutes after a stop and check of tires.  Even a flat or picking up something in the road should not cause a full scale tread separation. These are just poorly made tires. No symptoms of problems, just a cheap tire.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST226","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11603456,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/06/2024","dateComplaintFiled":"07/19/2024","vin":"5ZT3CT2B5M1","components":"STRUCTURE","summary":"Noticed interior night stand and paneling buckled. Upon inspection, found multiple welds on frame and hitch area that had separated due to poorly performed welds. Contacted both Forest River and Lippert. Neither were interested in this safety concern. The failures of these welds will result in this RV detaching from tow vehicle if not identified soon enough. Mine was very close to this!","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11602309,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/01/2024","dateComplaintFiled":"07/15/2024","vin":"5ZT3CK2B3M0","components":"TIRES","summary":"Shortly after buying the camper used in April of 2024 on the way home I had a tire blow out going about 60-65 miles. Date code of tire is 1520. The tire tread looked good and confirmed correct amount of tire psi before leaving the dealership with salesman.   While camper was parked, resting on 2x6 boards, not sitting directly on the ground. Where the tire was touching the board the tread completely split open. Date code also 1520.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"CASTLE ROCK ST","size":"ST235/80R16","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11550756,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/29/2023","dateComplaintFiled":"10/19/2023","vin":"4X4TCKH24MX","components":"TIRES","summary":"This is a summary of 2 passenger side tire failures:  First tire failure: On August 29, 2023 I packed up my Forest River Cherokee Black Label travel trailer in Perry, FL and relocated it to Tallahassee, FL.  On the way to Tallahassee on Highway 27 maybe a mile east of Capps, Fl noticed some tire debris behind me in side mirrors.  My girlfriend was following me, called and alerted me something appeared to be wrong and tire and other debris was coming off the bottom right side of the coach.  I was unable to pull over immediately due to traffic safety concerns and lack of side lane for parking.  I was able to park at Hwy 19 to I-10 exit at Capps, where assessed the situation.  The tire and rim was totally destroyed along with parts of the wheel well and skirt.  I was able to install the spare wheel and continue to Tallahassee.  Prior to moving the coach, I verified air pressure in all tires based on the side wall ratings using tire gauge and portable air compressor.  My speed was between 45mph and 55mph.  Second tire failure: This happened at Camping World repair shop around September 28, 2023.  Tire failure was on the same side as the previous one, right side of coach.  I was told the tire spontaneously exploded without any signs of tire failure prior.  As far as I know, there were no changes in air pressure or modifications to the wheel.  The wheel had been removed and inspected prior during axle maintenance.  I was told immediately after the the incident, they reduced air pressures on the remaining wheels for safety concerns.  Tires had no more than 2,000 miles and regularly checked inflation, travelling and parked.  I bought the coach new in 2022 and never noticed any tire rot, bulging or other or damage.  I\u2019m not confident remaining tires or replacements using Castle Rock products are safe and I am having all 4 tires replaced with brand new steel belted \"G\" rated tires fro reputable MFG.  These incidents have cost me thousands of dollars in repairs.  I contacted L","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"LIONSHEAD","productModel":"CASTLE ROCK","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11529914,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/01/2023","dateComplaintFiled":"07/01/2023","vin":"5ZT2CKFC7MY","components":"TIRES","summary":"Castle Rock ST Tire size ST 225/75R15 blew out on the way home from a camping trip. The tires are like new. No warning at all the tread just peeled away like a tin can on the highway causing lots of damage to my camper. I put the spare on and a week later I took it to the dealer so they could do an estimate on it for repairs the other tire blew out on the highway causing more damage to my camper.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"LIONSHEAD","productModel":"CASTLE ROCK","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11528001,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/18/2023","dateComplaintFiled":"06/20/2023","vin":"5ZT2CKEC7MY","components":"TIRES","summary":"Castle Rock ST 226 Tire P 205 / 75 R14 ST226 had catastrophic failure while properly inflated, far below rated load, and below rated speed.  The Towing company that inspected the tire and Discount Tire that replaced the tire both stated that the tire failed due to a defect.  Additionally, the immediate destruction of the tire caused significant damage to the vehicle wheel well and caused the travel trailer to veer off the road along a busy Interstate freeway.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST226","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11525428,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/27/2023","dateComplaintFiled":"06/05/2023","vin":"4X4TCKE20MX","components":"TIRES","summary":"Trailer tire installed by manufacturer was defective.  Tire was on the trailer when bought new.  Tire had less than 1000 miles and 2 years use.  Tire suffered a rupture/blowout while parked in driveway.  Trailer had been sitting stationary for two weeks.  Proper tire pressure was checked and maintained prior to and after each tow. Castle Rock ST Radial ST226  ST205/75R15 DOT JUJT 1MT Manufactured 4020","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11524683,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/15/2023","dateComplaintFiled":"05/31/2023","vin":"4X4TCKC22MX","components":"LATCHES/LOCKS/LINKAGES","summary":"The contact owns a 2021 Forest River Cherokee. The contact stated while attempting to enter the camper, it was difficult to open the front and rear doors. After a visual examination, the contact discovered that the doors were splitting at the base. The dealer was notified of the failure and advised the contact to submit a claim to the manufacturer. The vehicle has not been repaired. The manufacturer was notified and advised the contact that the doors were out of warranty, requiring the contact to purchase out-of-pocket to replace the doors. The failure mileage was unknown.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11524432,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/22/2023","dateComplaintFiled":"05/30/2023","vin":"4X4TCKC24MX","components":"UNKNOWN OR OTHER","summary":"My coach was purchased brand new, straight off the lot, 11/14/2020. On Mon, May 22, 2023, I came home to my black tank hanging out of the bottom of my camper. Upon inspection, the black tank had none of the straps underneath it and was not being held in place by the bracket because the bracket had been welded in backwards. Its amazing that this has not fallen completely out while it was traveling down the road.  I have been shuffled between the manufacturer, the dealer, my warranty people. I have sent several pictures and I need to know someone else I can speak with. Even if I was to get a new tank, that bracket will have to be cut off, turned around, and then welded back in place. This is not a \u201cmy camper is too old and my warranty has expired\u201d problem. This is a \u201cIt was made in your factory by someone that didn\u2019t pay attention to what they were doing\u201d manufacturer problem. This could have caused a serious accident and could be a liability if it could even be moved to the dealer for them to look at it. At this time, it is not operational because it is a liability.  This has been escalated to the National Highway Traffic Safety Administration and the Federal Trade Commission.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11518029,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/14/2023","dateComplaintFiled":"04/20/2023","vin":"5ZT2CKFC5MY","components":"TIRES","summary":"There was a sudden thread separation while trailer was being towed on a highway in Florida at about 65 MPH. The thread that came off the tire damaged the underbody of the travel trailer as seen in the pictures. These ST 225/75R15 trailer tires were installed by the manufacturer and were fabricated in WK12 2021. I am positive the tire was at 80 PSI as it was checked before the trip from Florida to North Carolina on  4/14/2023. I contacted the manufacturer Forest River and because the trailer is past the 1 year warranty, they recommended to talk to the tire manufacturer Lionshead, for which you receive a voicemail and asks you to fill out a warranty information. I will fill out the information and see what happens, but this incident could have caused a huge accident. If you google, \"castle rock thread separation\" - you will find multiple complaints in multiple forums about this issue. I hope it gets corrected and accidents prevented. Thank you, JP Ledermann","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"LIONSHEAD","productModel":"CASTLE ROCK","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11495500,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/27/2022","dateComplaintFiled":"11/30/2022","vin":"5ZT3CK1B0M0","components":"TIRES","summary":"Three tires blew up within a few hours of each other while traveling on I81/I75, the tires are available for inspection at my personal residence.  With a complete blow out each time finding a safe place to pull off the interstate was challenging, slowing traffic and speeding vehicles.  The tires were replaced while on the side of a busy interstate risking one's life in the process.  The tires have been inspected by 2 different tire stores of whom stated the tires are poorly made and \"garbage\".  The insurance company has been notified with a claim number issues however, the RV can not be inspected until December 15th (first available date).  Tires are continuously monitored with a Tire Pressure Monitoring System with readings of 79-82 psi.  There were absolutely no warnings or symptoms of an impending failure of the tires.  These tires are going to kill someone and should not be allowed to be sold in the U.S. let alone installed on new RV's.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST226","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11489719,"manufacturer":"Forest River, Inc.","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/15/2022","dateComplaintFiled":"10/18/2022","vin":"5zt3ctxb5m1","components":"ELECTRICAL SYSTEM","summary":"The electric fireplace in our RV caught on fire.  A visible flame was seen behind the fireplace glass near the thermostat display on the right side of the fireplace.  Visible smoke and burning smell observed from the upper right vents above the control panel buttons.  The fireplace unit itself had an audible alarm, in addition to the RV smoke detectors that were triggered.  We were inside the RV when this occurred, and once smoke and flame were observed, we immediately extinguished the fire by shutting off the master power breaker, and promptly removed the fireplace unit from the cabinet prior to any damage to the RV.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11483871,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/17/2022","dateComplaintFiled":"09/11/2022","vin":"5ZT2CTMB1M1","components":"TIRES","summary":"CASTLE ROCK RADIAL, ST 226 ST 225/75R15, LOAD RANGE E, DOT JULT 1MT 5019 75MPH 2021 WOLF PACK 23PACK15. TIRES HAVE LESS THAN 4,000 MILES. TIRES STILL HAVE 9/32 TREAD LEFT. LEFT REAR TIRE TREAD PEELED OFF WHEN TRAVLING ON THE HIGHWAY CAUSING OVER 4,000.00 DOLLARS IN DAMAGES TO THE UNDER SIDE OF TRAILER AND SLIDEOUT. NO IMPACT TO TIRE OR DID NOT HIT ANYTHING IN THE ROAD. TRAILER HAS TPMS SENSORS THAT READ ON MY DASH TIRE PRESSURE AND TEMP. NO WARRING TIRE STILL HAD AIR BUT TREAD PEELED OFF FROM THE STEEL BELTS. THE OTHER TIRES HAVE BUMPS IN THE TREAD AND ARE NOT SAFE TO USE. CONTACTED MY DEALER AND THEY STATED TIRES ARE [XXX] TIRES. NOT A GOOD ANSWER. WAS TOLD TO CONTACT LIONSHEAD TIRE AND WHEEL. I MADE A NUMBER OF CALLS WITH NO RESPONCE ONLY OPTION WAS TO FILL WARRANTY FORM. CONTACTED FOREST RIVER AND WAS TOLD I HAD TO CONTACT TIRE MANUFACTURE. I DID GET A RESPONCE BACK FROM LIONSHEAD TIRE THAT THEY WOULD PAY FOR ONE TIRE $105.00 NOTHING FOR THE OTHER TIRES, DAMAGES, LOSS OF USE OR DIMINISHED VALUE AS THE DAMAGES TO THE UNDERSIDE CAN NOT BE REPAIR TO PRELOSS CONDITION. WITH OVER 40 YEARS AUTOMOTIVE EXPERIENCE AND 30 YEARS RV EXPERIENCE THIS IS NOT NORMAL. I SEE A NUMBER OF COMPLAINTS WITH NO RESOLUTION. ***** HOPE SOMEONE WILL LOOK INTO THIS BEFORE SOMEONE GETS KILLED. NOT TO SAY IT DID NOT ALREADY HAPPEN JUST NOT REPORTED. *****  INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"LIONSHEAD","productModel":"CASTLE ROCK","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11482291,"manufacturer":"Forest River, Inc.","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/01/2022","dateComplaintFiled":"08/31/2022","vin":"5zt3ckubxm0","components":"ELECTRICAL SYSTEM","summary":"On the morning of August 1st, 2022 we were notified by a neighbor of some damage on our 2021 Artic Wolf 5th wheel. After inspection it appeared that a small fire had occurred earlier in the morning- unknown time and it apparently was contained to the one compartment without spreading. The previous evening the camper was fine. The fire was contained to a specific compartment which housed the water hook-up, cable hook-ups and the motion light. This was reported to our insurance who did an inspection and determined that most likely it was an electrical issue and started with the motion light. Upon discovery of the issue the trailer was unplugged and battery was disconnected.  We had gone camping the weekend before the fire happened. Unable to be \"recreated\". The insurance adjuster inspected it on 8/10/22. No concerns or issues the weekend before. We have been having issues with the light randomly staying on/not turning on etc.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11470948,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/25/2022","dateComplaintFiled":"06/25/2022","vin":"5ZT3CTXB2M1","components":"SUSPENSION,UNKNOWN OR OTHER","summary":"No current incidents that I'm aware of.   Landing gear on the 5th wheel isn't designed for this heavy trailer.  There is a potential for someone to be seriously hurt, or killed if they have to resort to using bottle Jack's to lift trailer.  Also the suspension is very weak, and i believe could break, and cause a major accident...","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11468741,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/02/2022","dateComplaintFiled":"06/11/2022","vin":"5ZT3CK1B1M0","components":"TIRES","summary":"Over a period of 2 months all four tires blew out while traveling with less than 3500 miles on them.  None of the tires blew out due to running over anything, each tire blew while traveling on interstate highways. Tires are ST225/75R15 Load Range E Castle Rock made by LionsHead Tire and Wheel, all 4 had DOT of JULT.  Tire pressure was maintained at 70 psi and driving speed was 60 mph with ambient temperatures ranging from 75 to 95 degrees.  Tires came with 5th wheel camper by Forrest River when purchased new in 2021.  Tires have been replaced and disposed of but pictures are attached.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"LIONSHEAD","productModel":"CASTLE ROCK","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11467060,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/27/2022","dateComplaintFiled":"06/01/2022","vin":"4X4TCKB20MK","components":"STRUCTURE","summary":"We have had our travel trailer for about 1 year and have had it in for service to the bedroom door as we noted it was sticking. This weekend the bedroom door failed. The frame of the door itself came away from the door making it difficult to open. At the same time the other entry door was stuck shut. My wife was unable to open the door. I was able to open it with great difficulty. The door side of the trailer was in direct afternoon sunlight it it appeared to have swollen and jammed itself in the doorway. It did not resolve itself until the outside temperature dropped and we ran the air-conditioning inside the trailer. If my wife would have been inside alone and would have needed to escape the trailer should would not have been able to. In researching forums and forest river related Facebook groups this appears to be a common issue.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11459767,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/05/2022","dateComplaintFiled":"04/05/2022","vin":"4x4tckb21mk","components":"STRUCTURE","summary":"Mounting nuts from body to frame are loose after only 2 years of use.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11459478,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/28/2022","dateComplaintFiled":"04/04/2022","vin":"4x4tckv28mk","components":"STRUCTURE","summary":"On my camper, there are bolts from the body through the frame to hold the two together. While inspecting my camper nearly all the bolts could be unscrewed by hand, with a few having a noticeable gap where they had backed away. There were only 3 bolts on the entire camper that were tight. If these bolts had continued to loosen it is possible the body could separate from the frame while driving.  I contacted the manufacturer over this issue and was told to inspect those bolts each time. Nowhere in the owners manual could I find where this is a requirement.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11456461,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/11/2022","dateComplaintFiled":"03/13/2022","vin":"5ZT2CTMB1M1","components":"TIRES","summary":"Towing the trailer at approximately 50 mph I seen in the rear view mirror the tread of 1 tire. The front drivers side come off of the tire and fly off and damage the wheel well and rip out the electrical going to the trailers pop out. The tire delaminated only loosing the tread the tire was still holding air pressure not leaking at all. I have contacted my insurance company they have not viewed in person. No police report was made. I have replaced all 4 tires for the safety of my family and still have damaged tire in my garage for proof of incident","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST226","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11451885,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/01/2022","dateComplaintFiled":"02/14/2022","vin":"4X4TCKA2XMK","components":"POWER TRAIN","summary":"I purchased a 2021 Cherokee Grey Wolf travel trailer in May of 2021. After pulling only twice I noticed that the unit side trekked when in tow towards the passenger side shifting the rear of the trailer approximately 6-8 inches toward the passenger side compared to the trailer's front body lines. I scheduled service for the unit at my locale Forest River Repair Shop where they identified that the 1 of the 2 axles were bent. This defect caused this unit to sway very dramatically at times when traveling down the road. It also increased the blind spot on the passenger side and increased tire wear due to the fact that the wheels were not in line with one  another which could have resulted in premature tire failure if not noticed.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11447319,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/15/2020","dateComplaintFiled":"01/13/2022","vin":"4X4TCKC22MK","components":"SUSPENSION","summary":"The contact owns a 2021 Forest River Cherokee RV. The contact stated that as the tires of the RV were frequently flat, the RV was taken to the dealer to determine the cause of the failure. The dealer diagnosed that one of the axles was bent due to the overloading of the RV. The contact stated that the dealer did not provide any further information on the axle that had failed. The contact stated that the load capacity of the two axles was 7,000 pounds, 3,500 pounds each. The contact stated that the load capacity of the RV was 7,934 pounds with a dry weight or unloaded weight of 5,960 pounds, which allowed him to load a maximum of 1,974 pounds per the manufacturer's instructions; however, the contact had never exceeded the maximum of 1,974 pounds when loading the RV even though the manufacturer\u2019s sticker indicated not to overload the camper with more than 1,500 pounds. The contact had been trying to reach the manufacturer and was awaiting a callback. The vehicle was not repaired. The failure mileage was approximately 1,900.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11446204,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/08/2021","dateComplaintFiled":"01/04/2022","vin":"4X4TCKC29MX","components":"TIRES","summary":"Castle Rock ST radial ST226 by Lionshead. Size ST225/75/R15 on the RV I purchased. I bought a new Forest River Cherokee 274RK in June 2021. On 10-08-2021 the first tire with a date code of 1120 had a blow out with the tread completely separating from the tire at 50 mph near Payson, UT. Doing damage to the underside of my trailer. I had the tire replaced at Wal-Mart in Payson, UT.   Then on Sunday 01-02-2021 a second tire exploded while the RV trailer is parked in Quartzsite, AZ. (the date code on that one was also 1120) it has been parked here since 10/11/2021 and has not moved. The second tire is available for inspection. I have not had the inspected.  DOT:  JULT 1MT Speed rating:  L Load range:  E","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."},{"type":"Tire","productYear":"9999","productMake":"CASTLE ROCK","productModel":"RADIAL ST226","size":"ST225/75R15","manufacturer":"Lionshead Specialty Tire & Wheel LLC"}]},{"odiNumber":11440914,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/18/2021","dateComplaintFiled":"11/18/2021","vin":"5zt2ckec3my","components":"SUSPENSION","summary":"The contact owns a 2021 Forest River Cherokee Travel trailer. The contact stated that while the travel trailer was parked at a park, the contact performed an inspection and noticed a metal bar had fractured and detached from the rear passenger's side shock. A park host informed the contact that she could not drive the travel trailer on the highway. The travel trailer was towed to the dealer and diagnosed that the shocks were too small to handle the weight of the travel trailer. The travel trailer was not repaired and remained at the dealer. The manufacturer was made aware of the failure and informed the contact that the shocks were adequate for the weight of the travel trailer.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11431111,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/30/2021","dateComplaintFiled":"08/30/2021","vin":"5ZT2CKECXMY","components":"TIRES","summary":"The contact owns a 2021 Forest River Cherokee travel trailer. The contact stated that while driving 20 MPH, the rear spare tire had detached from the fifth wheel onto the roadway. The contact was made aware of the failure after parking the travel trailer and noticed that the rear spare tire was missing. The dealer and manufacturer were not made aware of the failure.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11429723,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/01/2021","dateComplaintFiled":"08/19/2021","vin":"5zt3ckub2m0","components":"ELECTRICAL SYSTEM","summary":"The contact owns a 2021 Forest River Cherokee. The contact stated that he experienced several electrical failures with the trailer including a defective refrigerator. Upon investigation, the contact discovered that the wiring within the circuit breaker panel was not properly secured. Upon further investigation, the contact discovered that the propane wiring was crimped and not properly secured, which he stated could lead to a severe failure. The contact was able to repair the wiring failures himself. The manufacturer was notified of the failure and the contact was informed that he would receive a call back. The contact had not received a response despite numerous attempts to reach the manufacturer by phone and email. The dealer was also notified of the failure and denied reimbursement to the contact for the repairs. The vehicle was repaired. The failure mileage was approximately 2,000. Consumer stated where it says propane wiring it should say main propane supply line was crimped causing leakage. Issues with electrical and loss of power once in awhile, 12 volt line black unattached.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11425650,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/02/2021","dateComplaintFiled":"07/20/2021","vin":"5zt2ckec6my","components":"SUSPENSION,UNKNOWN OR OTHER","summary":"On my 2021 Forest River Cherokee Wolf Pup 16TS, I observed on the passenger side frame where the wheel is that at some point the axle/leaf spring components came in contact (perhaps many times) with the frame of the trailer. This had made a noticeable dent in the frame. The trailer was not heavily loaded and within GVAWR, GVWR, & CCC limits. From my observations, had I not already changed out the brake assembly's after discovering a failed component inside them, it is clear that the axle collision would have severed the electric brake cables resulting in the trailer brakes being unable to respond and/or failing altogether. My personal assessment of this is that the combination of the 3500lb rated axle as well as the capacity of the leaf springs on these trailers is not sufficient enough to account for allowed cargo weight, plus standard road conditions to avoid having the axle come in contact with the frame above it.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11425493,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/18/2021","dateComplaintFiled":"07/19/2021","vin":"5zt2ckec4my","components":"SERVICE BRAKES, HYDRAULIC","summary":"The contact owns a 2013 Ford F-150 used for hauling a 2021 Forest River Cherokee Wolf Pup travel trailer. The contact stated that while driving at 5 mph, the trailer disconnected warning light was illuminated. The contact pulled over and inspected underneath the travel trailer and found that the brake line was fractured and had detached. The contact reattached the brake line with electrical tape however, the failure recurred. The contact noticed upon inspection that there were two brake lines that had fractured and were detached. The dealer was made aware of the failure but informed the contact that it would be several months before the RV could be diagnose or repaired. The contact left a voicemail to notify the manufacturer of the failure and was awaiting a callback. The failure mileage was 7,000.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11423652,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/25/2021","dateComplaintFiled":"07/06/2021","vin":"5ZT3CTXB4M1","components":"UNKNOWN OR OTHER","summary":"I purchased a 2021 315Pack12 last Aug 2020 -  Vin Number [XXX].   During some routine maintenance on 6/26/2021, I noticed that the factory had mounted a propane hose so that it was being pressed hard against a support bar on the underbody of the trailer.   It was being held against the support bar by a propane splitter that was mounted to the underbody frame.  The pointy part of the support bar was digging into the hose.   (see pictures).  Had this issue not been discovered it could have led to a serious propane leak and in worse case could have resulted in the trailer burning to the ground and/or possible personal injury.   This is a very dangerous installation and I would suggest that all 315s (Forest River Toy haulers) be inspected for this issue.  At this point I have corrected the issue myself by installing a \u00be\u201d spacer between the frame and the splitter (see pictures).   However, the propane hose was compromised (see pictures).  I have asked Forest River to have a dealer near me replace this hose ASAP.   Forest River has not responded to my e-mails to date.   ****The installation location is on the underbody right frame, approximately 21\u201d in front of the right side forward tire.     INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11422760,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/14/2021","dateComplaintFiled":"06/29/2021","vin":"5zt2ckec1my","components":"STRUCTURE,UNKNOWN OR OTHER","summary":"Our travel trailer door on a 2021 forrest river fell off while driving and is stuck open.    They have been trying to fix it for since April 17th but are now ghosting me after telling me it was a known issue with the new door system they are using.   2ndly there is metal shards and shavings under my sink in the fridge area and no one seems to know why there is busted metal all over some electrical components.    Also the outdoor shower door and the side compartment door are falling off and will not stay closed during operation.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11419386,"manufacturer":"Forest River, Inc.","crash":true,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/24/2021","dateComplaintFiled":"06/02/2021","vin":"5ZT3CKUB7M0","components":"UNKNOWN OR OTHER","summary":"The Kingpin ripped away from the pinbox on our 5th wheel.  We were told by some that it appears to be inferior material and/or poor weld.  Our truck almost flipped down the hill where our rv landed.  Others could have been injured or killed had the RV gone a different direction.  I have contacted the RV manufacturer and currently awaiting a response. No warnings.  Police and tow drivers said they have never seen this in over 50 years of service.  Photos available.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11416131,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/11/2021","dateComplaintFiled":"05/11/2021","vin":"5ZT2CKEC8MY","components":"SUSPENSION","summary":"TRAILER WAS BUILT WITH THE DRY WEIGHT OF 3,527 POUNDS. FACTORY INSTALLED AN AXLE AND SUSPENSION THAT IS RATED AT 3,500 POUNDS. I'M CONCERNED THAT THIS WILL BE UNSAFE TO OPERATE ON THE ROADWAY AS THE COMPONENTS WEAR. CURRENTLY THE LEAF SPRINGS ARE ALMOST COMPLETELY FLAT WITHOUT ANY EXTRA LOAD IN THE TRAILER.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11412752,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/12/2021","dateComplaintFiled":"04/18/2021","vin":"5ZT2CKEC9MY","components":"SERVICE BRAKES","summary":"WHILE TAKING OUR FIRST TRIP TO THE COAST OF NC FROM RALEIGH, I WAS DRIVING DOWN THE ROAD, AND GOT A MESSAGE ON MY DASH SAYING TO CHECK TRAILER CONNECTIONS. WE PULLED OVER AND CHECKED, AND THE CONNECTOR WAS SEATED, AND EVERYTHING SEEM TO BE WORKING. WHEN WE GOT TO THE CAMPGROUND, I HAPPENED TO BE LOOKING UNDER THE CAMPER, AND FOUND THE WIRES THAT FEED THE ELECTRIC BRAKES WERE CUT. THEY WERE PINCHED BETWEEN THE U-BOLTS ON THE AXLE AND THE FRAME. I HAD A MOBILE RV TECH REPAIR IT SO I COULD SAFELY DRIVE IT HOME. IF IT HAPPENED ON A TRIP TO THE MOUNTAINS, IT COULD HAVE BEEN A REAL PROBLEM.  I FOUND FROM FORUMS AND ON FACEBOOK, WE ARE NOT THE ONLY ONES HAVING THE PROBLEM, AND ONE PERSON FOUND HIS WIRES IN THE SAME PLACE TO HAVE THE SAME OUTCOME (HE SAID \" MINE WAS ON THE CHOPPING BLOCK ALSO) AND HE WAS GOING TO FIX THE PROBLEM.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11399751,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/06/2021","dateComplaintFiled":"03/08/2021","vin":"4X4TCKC27MK","components":"STRUCTURE","summary":"TL* THE CONTACT OWNS A 2021 FOREST RIVER CHEROKEE. THE CONTACT STATED THAT THE SAFETY CHAINS WERE WELDED INCORRECTLY ON THE HOOKUP AREA OF RV. THE CONTACT SPOKE TO THE LOCAL DEALER AC NELSEN RV WORLD - OMAHA (11818 L ST, OMAHA, NE 68137, (402) 333-1122) AND WAS INFORMED TO TOW THE RV IN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE CONTACT WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS UNKNOWN.*DT  CONSUMER STATED SAFETY CHAINS FELL OFF IN FRONT OF THE CAMPER.*JB*DT*JB*DT","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11374518,"manufacturer":"Forest River, Inc.","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/06/2020","dateComplaintFiled":"11/13/2020","vin":"5ZT3CK1B4M0","components":"TIRES","summary":"TL* THE CONTACT OWNS A 2021 FOREST RIVER CHEROKEE EQUIPPED WITH TIRE BRAND: CASTLEROCK TIRES, TIRE LINE: ST226, TIRE SIZE: 225/75/R15, DOT # JULT1NT. THE CONTACT STATED THAT THE REAR DRIVER'S SIDE TIRE BLEW OUT WHILE THE VEHICLE WAS TRAVELLING DOWN THE HIGHWAY AT 65 MPH. THE CONTACT TRIED TO SLOW DOWN BY APPLYING THE BRAKES AND THE TRAILER STARTED TO SWERVE.THE CONTACT SAW WHITE SMOKE IN HIS REAR VIEW MIRROR BUT WAS FINALLY ABLE TO PULL THE TRAILER OFF THE ROAD , EASE UP ON THE BRAKES AND CAME TO A GRADUAL STOP.   THE CONTACT WAS ABLE TO CHANGE THE TIRE AND TOOK IT TO A TIRE STORE. THEY NOTICED THE OTHER TIRES WERE ALL WEARING DOWN THE CENTER TREAD AND WOULD EVENTUALLY BLOW OUT AS WELL. THE CONTACT HAD THE ONE TIRE REPLACED AT THE TIRE SHOP. THE TRAILER DEALER  CAMPING WORLD OF POTEAU 34203 US-59, POTEAU, OK 74953 (877) 886-6503 GAVE THE CONTACT THE TIRE WARRANTY AGREEMENT TO GET THE TIRE EXPENSE REIMBURSED. THE OTHER THREE TIRES WERE NOT COVERED FOR REPLACEMENT. THE RV MANUFACTURER JUST PROVIDED A QUESTIONER FOR THE CONTACT AND PROMISED A CALLBACK. THE OTHER THREE TIRES HAD NOT BEEN REPLACED. THE FAILURE MILEAGE ON THE RV VEHICLE WAS 870. THE TIRE FAILURE MILEAGE WAS 1,000.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11340895,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/21/2020","dateComplaintFiled":"07/22/2020","vin":"5ZT2CKRB7M2","components":"WHEELS","summary":"THE ALUMINUM WHEELS BEING USED ON THE FOREST RIVER CHEROKEE BUILT TRAVEL TRAILERS ARE DEFECTIVE.  THE WHEELS HAVE PIN HOLES WHICH ALLOW AIR TO ESCAPE AND CAN CAUSE AN OUT OF CONTROL CONDITION AT HIGHWAY SPEEDS.  AIR SLOWLY LEAKS OUT OF THE TIRES WHILE YOU ARE DRIVING AT HIGHWAY SPEEDS. THE WHEELS HAVE A CASTING OF DOT-T MADE IN CHINA BY SR WHEELS.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]},{"odiNumber":11338609,"manufacturer":"Forest River, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/10/2020","dateComplaintFiled":"07/10/2020","vin":"5ZT2CKRB8M2","components":"UNKNOWN OR OTHER","summary":"THE BRACKETS TO THE AWNING ON OUR 2021 CHEROKEE ALPHA WOLF TRAILER IS SCREWED IN TO THE WALL ON THE OUTSIDE OF THE TRAILER USING 1-INCH SCREWS. IT CAME OUT AND BENT THE BRACKET ATTACHED TO THE SIDE WALL OF THE TRAILER AFTER THE FIRST RAIN. HAVE ONLY OWNED IT 30 DAYS!!  DEALER WILL NOT FIX IT, SAYS AWNING SHOULD NOT BE OPEN DURING A RAIN, EVEN THOUGH WE HAVE NEVER HAD ISSUES WITH ANY OTHER CAMPER AWNING WE HAVE EVER OWNED. OTHER TRAILERS IN THE CAMPGROUND HAD NO ISSUES WITH THEIR AWNING.","products":[{"type":"Vehicle","productYear":"2021","productMake":"FOREST RIVER","productModel":"CHEROKEE","manufacturer":"Forest River, Inc."}]}]}