{"count":49,"message":"Results returned successfully","results":[{"odiNumber":11761037,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/01/2026","dateComplaintFiled":"08/31/2026","vin":"1FTEW1EG5JF","components":"ENGINE","summary":"I own a 2018 Ford F-150 3.5L EcoBoost with approximately 93,000 miles. I am experiencing a repeated cold start cam phaser rattle. This is a known issue addressed by Ford in several TSBs, including 19-2365, yet no recall has been issued. It has been \"repaired\" once at approximately 40,000 miles only to have the same issue reoccur at which time I was told that rattling at startup is \"normal\" and \"since it doesn't persist it is not an issue\".  No IC gasoline engine should rattle on startup, and I believe this defect poses long-term reliability concerns and will lead to engine damage and failure during operation.  Ford should be held responsible for a widespread design flaw affecting thousands of vehicles. I urge the NHTSA to investigate this recurring issue and hold Ford accountable for consumer safety and financial impact.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759735,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/18/2026","dateComplaintFiled":"08/26/2026","vin":"1FTEW1EG2JF","components":"POWER TRAIN,WHEELS","summary":"I own a 2018 Ford F-150 4WD with approximately 24,600 miles.  While traveling approximately 70 MPH on the highway in 2H with cruise control operating, I suddenly heard an extremely loud metal-on-metal grinding/ratcheting noise from the driver's-side front wheel area. The noise caused immediate concern about a possible front wheel or drivetrain failure. I disengaged cruise control and the grinding stopped.  Within approximately 50 miles on the same trip, the grinding occurred a second time while again traveling approximately 70 MPH in 2H without cruise engaged. Because of the severity of the noise, I pulled over on the side of the highway and inspected the vehicle. I found nothing visibly wrong and resumed driving.  The condition has since occurred two additional times while accelerating from a stop in 2H. These incidents were less severe but involved the same metal-on-metal grinding/ratcheting from the driver's-side front wheel area. I have also noticed a brief air/vacuum-type \"whoosh\" immediately before the grinding occurs.  My Ford service manager directed me to Ford TSB 24-2188, which addresses grinding/clicking/ratcheting from the front wheel area associated with partial engagement of the Integrated Wheel End (IWE). The truck is scheduled for diagnosis but has not yet been formally diagnosed.  I contacted Ford Customer Satisfaction, case CXH-090-0329-26-V5R9-P-5. Ford declined assistance due to vehicle age despite the low mileage.  I am reporting this because the condition has occurred four times, including twice unexpectedly at 70 MPH. I am concerned about the safety implications of a front wheel-end component potentially partially engaging at highway speed and believe this warrants NHTSA review.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759856,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/26/2026","dateComplaintFiled":"08/26/2026","vin":"1FTFW1RG8JF","components":"SERVICE BRAKES","summary":"My 2018 Ford F-150 is experiencing a dangerous loss of braking power, a soft/spongy brake pedal, and brake fluid leaking from the master cylinder into the brake booster. These are the exact symptoms and component failures described in Ford Recall Campaign 25S37 (NHTSA Campaign 25V236). However, when checking my VIN, I am told my truck is excluded from the recall population. Because my vehicle is exhibiting the identical safety defect, the current recall window is too narrow and needs to be expanded to cover my vehicle before a serious collision occurs.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759756,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/26/2026","dateComplaintFiled":"08/26/2026","vin":"1FTEX1EP9JF","components":"STRUCTURE","summary":"The contact owns a 2018 Ford F-150. The contact stated that the lock mechanism to drop the spare tire was rusted and failed to function as intended. The contact stated that the failure failed to allow for the spare tire from being lowered. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed. However, the dealer confirmed that the lock was rusted. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 105,000.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759370,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/01/2026","dateComplaintFiled":"08/25/2026","vin":"1ftex1c57jf","components":"ENGINE","summary":"Engine has cut off while driving on several occasions.  An accident nearly occurred as a result on at least 2 occasions.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759569,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/25/2026","dateComplaintFiled":"08/25/2026","vin":"1FTEX1CP0JK","components":"UNKNOWN OR OTHER,FORWARD COLLISION AVOIDANCE","summary":"I was required to complete the recall 24E12 on my 2018 ford F 150 2.7L eco boost XLT. Upon completion the check engine light comes on. I looked into this and this is an ongoing problem with the emissions recall . I scanned for a code and P0430 is coming up. (Catalyst System). I contacted the dealership and ford corporate and they will not help assist in resolving this issue. I explained my vehicle was working fine until the mandatory emissions recall was completed and that under the good will assistance I should be covered for Some compensation fixing this vehicle. I was denied any additional help. I as a loyal customer for many years don\u2019t believe that it is my responsibility to pay a full bill for a new converter when it was their recall that caused the issue on an already perfectly fine vehicle.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759375,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/25/2026","dateComplaintFiled":"08/25/2026","vin":"1FTEW1EP9JF","components":"AIR BAGS","summary":"The contact owns a 2018 Ford F-150.  The contact stated that the steering wheel cover covering the driver\u2019s side air bag was cracked. The dealer was contacted and stated that a special engineer was needed for the repair because the crack was located on air bag housing. The manufacturer was not made aware of the failure. The failure mileage was approximately 119,000.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759042,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/22/2026","dateComplaintFiled":"08/24/2026","vin":"1FTFW1E19JF","components":"POWER TRAIN","summary":"Truck will not shift into 7th gear, will down shift to 1st gear once it reaches 6th gear around 40mph. Causing the vehicle back tires to brake and skid and lose control of vehicle.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11759143,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/19/2026","dateComplaintFiled":"08/24/2026","vin":"1FTEW1E52JK","components":"POWER TRAIN","summary":"While driving home from a work appointment in Rockwall, Texas, I entered an intersection with three lanes of uncontrolled cross traffic traveling approximately 35-45 mph. As I accelerated my Ford F-150 equipped with the 10R80 transmission, it started into the intersection and then began sporadically hunting for a gear. The truck suddenly lost nearly all acceleration and slowed to an almost complete stop while I was in the middle of the intersection. Vehicles were approaching me from the driver side, leaving me with almost no ability to get out of their path. I was extremely fortunate that I was not T-boned. This is the second time this truck has experienced a sudden and dangerous loss of acceleration, the first was with a 4th gear slip on an on-ramp. Neither incident was preceded by a warning light or other dashboard indication. I understand Ford has been aware of problems involving the CDF clutch drum in the 10R80 transmission and that the design was subsequently revised in later versions. My vehicles issues are textbook CDF Drum problems. Meanwhile, the known 10R80 problems have significantly reduced the vehicle's value, leaving me owing more than I can reasonably recover by selling it. This is not simply a reliability issue. A transmission that can unexpectedly eliminate a vehicle's ability to accelerate without warning is a serious safety hazard. Twice, this defect has put me in a situation where I could have been killed by cross traffic. I am asking NHTSA to investigate the 10R80 transmission, including the CDF drum/design issues, and determine whether these failures create an unreasonable safety risk and whether Ford has taken adequate corrective action.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11758239,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/01/2026","dateComplaintFiled":"08/20/2026","vin":"1FTEW1EPXJF","components":"ENGINE","summary":"I believe there\u2019s an ongoing lawsuit against Ford regarding these truck models, specifically their gearboxes, which are failing and slipping gears. After the initial recall for the new software gearbox mapping, my gearbox has started slipping, causing issues during downshifting, acceleration, and upshifting. There are frequent loud bangs","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11758222,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/20/2026","dateComplaintFiled":"08/20/2026","vin":"1FTFX1EG1JF","components":"ELECTRICAL SYSTEM","summary":"Odometer Fraud. The contact owns a 2018 Ford F-150. The contact stated that while attempting to trade in the vehicle, there was a mileage discrepancy discovered. The vehicle was a private sale. The mileage at the time of the purchase was approximately 93,000 miles, which was displayed on the odometer; however, the trade-in dealer informed the contact that the vehicle history report listed the mileage at over 190,000.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11758290,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/22/2026","dateComplaintFiled":"08/20/2026","vin":"1FTFW1E57JF","components":"SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,POWER TRAIN","summary":"The contact owns a 2018 Ford F-150. The contact stated that while driving 55 MPH on the highway, the vehicle lost motive power, and the brakes became inoperable. The drivetrain and wrench symbol were displayed. The ABS warning light was illuminated and DTC: U100 (Failure of Communication for Engine and Transmission) was displayed. The codes were cleared after restarting the vehicle. The vehicle was taken to the local dealer, where it was diagnosed with a communication error with the engine and transmission computer. The vehicle was repaired, but the failure reoccurred. The transmission upshifted from first gear to seventh. After a while, the vehicle resumed normal operations, but then the vehicle drove abnormally. The RPM increased to high, and the temperature gauge was at HOT. The vehicle was taken back to the dealer and was diagnosed with complete transmission failure. The vehicle had not been repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 62,513.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11757451,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/07/2026","dateComplaintFiled":"08/17/2026","vin":"1FTEW1EG4JF","components":"POWER TRAIN","summary":"My 10R80 transmission has failed at 79000 miles.  This tranmission has been problematic during the life of this truck.  Hard shifting, delayed shift, clutch flutter.  Ford refused to honor my extended warranty that covers the power train beyond the 5/60000mile base warranty.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11757273,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/05/2026","dateComplaintFiled":"08/16/2026","vin":"1FTEW1EG3JF","components":"POWER TRAIN,ENGINE","summary":"Truck starting missing gears when pulling onto highway. Rpms jumped high and truck wouldnt shift. Thankfully we made it across before the oncoming traffic or we would have been hit. Finally got it to go but it was missing gears causing it to drive sluggish. No prior engine lights warning me. When the incident happed I got a notification of a power train malfunction/ reduced power.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756719,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/23/2026","dateComplaintFiled":"08/13/2026","vin":"1FTEW1C56JF","components":"POWER TRAIN","summary":"10R80 transmission will jerk and hard shift randomly at times. Also appears to get stuck in gear and/or downshift at inappropriate times.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756744,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/23/2026","dateComplaintFiled":"08/13/2026","vin":"1FTEW1EP1JF","components":"POWER TRAIN","summary":"Transmission shudders until it gets warm, then it slips when accelerating after it's warmed up. Sometimes it goes completely out of gear. I've had the recall update done on the TCM and it made it worse. It has been confirmed by a service center. There are no messages or warning lights and it started slipping 6-8 months ago and has gotten worse. I cannot drive it currently.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756776,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/01/2026","dateComplaintFiled":"08/13/2026","vin":"1FTEW1EG4JF","components":"POWER TRAIN","summary":"While driving, the automatic transmission started to act up. The truck would attempt to go into 3rd gear but would bypass it to 4th, similar action around 7/8th gear. When pressing the accelerator at times, the truck would not switch gears or increase speed. A warning light did appear on the dashboard, indicating a problem. A code reader indicated two possible issues related to the transmission.  These issues made the truck unsafe to drive in any traffic since I wasn't sure the truck was going to continue moving and was concerned about being either being stranded or being rear-ended. The truck was taken to a repair shop that my extended warranty works with. The shop was able to reproduce the issue. The shop indicated that there was an issue with the transmission. A warranty company technician came to the shop to run a diagnostic on the truck. After review of the technicians analysis, the warranty company approved the transmission repair and shop is waiting on parts.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756402,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/15/2026","dateComplaintFiled":"08/12/2026","vin":"1FTEX1EP3JK","components":"POWER TRAIN","summary":"Around 108018 miles started to experience rough, harsh, slamming shifts and skipping gears from 1 to 4 or 3 to 6 and then from 8 slamming to 1st gear at times very unsafe and erratic and through my research this transmission has been a big problem on Fords. I took to a local transmission repair shop they drove and confirmed the shifting issues and said yes the valve body/shift solenoids need replaced and also the CDF drum/cylinder is going bad they also dropped the oil pan and confirmed metal/aluminum shavings in the bottom of the pan. I was quoted $8,800 to repair and this is a huge expense that Ford knows of the problem and needs to be held accountable. there needs to be a recall to replace these bad transmissions with new updated units.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756430,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/14/2025","dateComplaintFiled":"08/12/2026","vin":"1FTEW1CP6JF","components":"POWER TRAIN","summary":"Vehicle was traveling at highway speeds when the transmission decided to shift from 10th gear into 1st gear at 70mph. Had vehicle at dealership and the transmission had to be replaced. Could have destroyed the motor or caused massive accident on highway shifting into 1st gear at 70mph.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756484,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/14/2026","dateComplaintFiled":"08/12/2026","vin":"1FTFW1EG8JF","components":"POWER TRAIN","summary":"I have 40,000 miles on this truck and the torque converter shutters when towing, the transmission is slow to shift fome 3-4.  No one has looked at it.  Since its out of warranty I am just going to run it until it fails.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756492,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/01/2026","dateComplaintFiled":"08/12/2026","vin":"1ftfx1e5xjk","components":"POWER TRAIN","summary":"The internal mechanical failure of the Ford 10r80 transmission due to design fault causes unsafe driving conditions as the transmission stalls (fails to power at request) or lunges (powers forward without driver input) causing unsafe conditions for vehicle occupants and nearby vehicular & pedestrian traffic.  My vehicle exhibits two well known and documented conditions; stalling and lunging forward.  The most common failure is that the transmission fails to shift from 1st to 3rd gear in a low speed condition (e.g. navigating parking lots amongst pedestrians). Upon the failure to shift, the vehicles computer system senses this, overrides by raising the vehicle RPMs significantly without driver input to do so, the vehicle then hard shifts and jerks forward several feet in an uncontrollable manner. Anticipating the jerk and overriding with the brakes fails to stop the vehicle from lunging forward.  The second most common failure is the transmission totally failing to provide drive. A common scenario would be sitting at a traffic light waiting to make a left turn. Upon the opportunity to make a safe left turn, the vehicle at times will roll slightly forward (in its first gear), it will then attempt a shift while the vehicle may potentially still be in cross-traffic, and the vehicle at times will fail to drive, without any inputs (brake, gas, manual shift) getting the vehicle out of the no-drive condition, and leaving the vehicle subject to a dangerous potential for collision or safety hazard.  The issues with the 10r80 transmission failures are well documented, well understood by Ford Motor Company, and specific to my vehicle have been identified by a reputable dealer as requiring repair. My vehicle's transmission is exhibiting failure at 47,000 miles.  No warning indications exist prior, during or after this repeatable incident.  Ford has since fixed the design flaw, but refuses to address the safety issue with vehicles manufactured before the re-design.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756525,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/20/2026","dateComplaintFiled":"08/12/2026","vin":"1FTEW1E5XJF","components":"POWER TRAIN","summary":"Cdf drum went bad had to have transmission replaced because of how hard it was shifting","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756603,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/13/2026","dateComplaintFiled":"08/12/2026","vin":"1FTEW1EP1JF","components":"POWER TRAIN","summary":"When shifting from 3rd to 4th gear, the trucks RPM jumps and then downshifts into first gear. This happens around 40 mph and has almost caused two accidents for me.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756117,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/28/2026","dateComplaintFiled":"08/11/2026","vin":"1FTew1EG1jf","components":"POWER TRAIN","summary":"I am reporting a safety-related transmission problem I experienced with my 2018 Ford F-150 XLT equipped with the 10R80 automatic transmission. While driving normally, the transmission suddenly lost power and failed to engage into gear causing hesitation in the middle of driving.  This occurred while in stop and go traffic, creating a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion.  I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion.  This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard.  Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to determine whether this is a safety defect requiring a recall.  I believe owners should not have to wait for a potentially dangerous transmission failure before this known condition is addressed.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756245,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/16/2026","dateComplaintFiled":"08/11/2026","vin":"1FTEW1E53JF","components":"POWER TRAIN","summary":"Truck downshifted to a gear too low for the travel speed, caused the rear tires to briefly lock up, very lucky to have kept control. Unsure why the truck did it, it\u2019s happened twice now at 89,000 miles.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756317,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/09/2026","dateComplaintFiled":"08/11/2026","vin":"1FTEW1CP1JK","components":"SERVICE BRAKES, HYDRAULIC","summary":"The contact owns a 2018 Ford F-150. The contact stated that while driving 55 MPH, the message \"Brake Fluid Level Low\" was displayed. The brake pedal was depressed and went to the floorboard. The contact stated that the brakes failed to work properly. The contact drove to Walmart and purchased brake fluid to add to the vehicle, but the failure persisted. The contact added more brake fluid, but the failure recurred, and the engine made a knocking sound with smoke coming from the exhaust pipe. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 22V150000  (Service Brakes, Hydraulic); however, the VIN was not included in the recall. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 114,089.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756002,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/13/2025","dateComplaintFiled":"08/10/2026","vin":"1FTFW1EG1JF","components":"POWER TRAIN,ENGINE","summary":"10r80 transmission CDF Failure. Had repair completed though still has issues with 4/5th gear. Truck will lose power while accelerating until it finds the gear it wants to go. Multiple re-learning processes completed with no solution. V6 ecoboost - cam phasers repaired twice. 1st time by initial owner but that was not relayed to me. 2nd time by me after multiple trips to the dealership where they couldn't reproduce the issue. Took videos and finally brought the truck in with the check engine light flashing. Required entire engine rebuild.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756050,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/07/2026","dateComplaintFiled":"08/10/2026","vin":"1FTFW1E59JF","components":"POWER TRAIN","summary":"Hello, I have a concern with my trucks transmission. I haven't had it diagnosed by Ford but am an independent tech myself. I believe the cdf drum is failing. Here are the problems I had. The biggest is the safety. I was pulling out on busy street and I accelerated. Truck moved and the transmission delayed in shifting causing truck to slow down and then slamming into gear. Oncoming traffic got very close. It has done it numerous times. I don't know when it will do it and when it won't. Transmission has also gone from 3rd gear to 8th and back to 2nd on its own.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11756060,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/10/2026","dateComplaintFiled":"08/10/2026","vin":"1FTEW1E50JF","components":"POWER TRAIN","summary":"The 10 speed transmission will downshift unexpectedly at unsafe speeds. The CDF drum issues make this vehicle unsafe.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11755803,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/15/2025","dateComplaintFiled":"08/09/2026","vin":"1FTEW1EGXJK","components":"POWER TRAIN,UNKNOWN OR OTHER","summary":"When driving my vehicle, it severely downshifts and whiplashes/jerks you. We no longer drive it and have parked it and no longer feel safe. No lights came on dash to give us any type of warning.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11755664,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/08/2026","dateComplaintFiled":"08/08/2026","vin":"1FTFW1EG6JF","components":"POWER TRAIN","summary":"The transmission is failing. It is a known issue. 2018 Ford F150 Lariat. The transmission shifts very hard; it's slipping out of gear. It is getting stuck in gears and not shifting as it should. It is flaring when shifting gears. My safety is at risk because I never know when the vehicle is going to move if I am stopped. It could happen in the middle of an intersection; it could go out when I'm going at highway speeds. Yes, the problem has been confirmed by a Ford dealer. The component has not been inspected by anyone on my personal vehicle except by the Ford technician at a local dealership. There were no warning lamps or messages. At first, when you would pull out for the first time of the day, it would have a little trouble shifting through 3rd and 4th gear for the first few minutes, then it was fine the rest of the day. Now it is slipping out of gears, shifting hard, missing shifts, banging when shifting gears, flaring when shifting gears, getting stuck in gears. I did not know this was an issue before buying the vehicle. After it started occurring, I looked it up, and this is a VERY widely known issue with this Ford 10R80 transmission in multiple models of their vehicles, and they REFUSE to recall them. This is an incredible safety issue, as the vehicle can slip out of gear or randomly change to the wrong gear at any time and make the driver lose control of the vehicle.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11755476,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/26/2026","dateComplaintFiled":"08/07/2026","vin":"1FTEW1CP4JK","components":"SERVICE BRAKES","summary":"While engaging my brakes at a traffic light, suddenly the brake pedal went to the floor. Once I was able to safely park the vehicle (because there was no brake function), I inspected around the tires, brake fluid, and brake calipers. I noticed a puddling of brake fluid around the front passenger tire. Upon removing the tire, and inspecting this brake hose, I noticed the brake hose was visibly ruptured. I went to a local Ford dealership to purchase the replacement part, and fix this issue.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11755177,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/15/2026","dateComplaintFiled":"08/06/2026","vin":"1FTFW1EG8JK","components":"POWER TRAIN","summary":"I have had my 2018 10R80 transmission get hung in gear and not be able to take off in traffic and also downshifting on its own and loosing a few gears while driving vehicle on highway. I see where Ford did a CDF drum change on newer model transmissions but nothing has been done on 2018???? To me this is a safety issue that needs to be resolved!!","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11755261,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/10/2026","dateComplaintFiled":"08/06/2026","vin":"1FTEW1E59JF","components":"POWER TRAIN","summary":"Harsh downshifting in transmission. Drops down from 10 to 1 then back to 7 then to 1 and then it fine for awhile and the repeats","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11754871,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/03/2026","dateComplaintFiled":"08/04/2026","vin":"1FTFW1EG7JF","components":"POWER TRAIN","summary":"I live on a busy road on top of a hill. When leaving the truck will often hesitate leaving me with a heavy loss of acceleration. I\u2019ve I been in numerous situations were I was almost rear ended! The truck will also jolt you when it shifts  like hitting a wall.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11754675,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/01/2025","dateComplaintFiled":"08/04/2026","vin":"1FTEW1CPXJK","components":"POWER TRAIN","summary":"The contact owns a 2018 Ford F-150. The contact stated that while driving at undisclosed speeds, the vehicle hesitated, decelerated unintendedly, and the transmission was slipping. The check engine and the WRENCH Icon warning lights were illuminated. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer and manufacturer was notified of the failure, but no assistance was provided. The contact was informed that the VIN was not included in the extended powertrain warranty coverage for the failure. The failure mileage was 119,000.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11754195,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/03/2022","dateComplaintFiled":"08/01/2026","vin":"1FTEW1EP1JF","components":"POWER TRAIN","summary":"I am reporting a severe safety hazard regarding my 2018 Ford F-150, which is equipped with the 10R80 10-speed automatic transmission. While driving, the transmission suddenly lost its selected gear, slipped, and failed to engage. This event was accompanied by violent shifting, severe RPM flaring, and unexpected, harsh downshifts.This dangerous failure occurred during critical driving maneuvers\u2014specifically while accelerating and attempting to merge onto a highway\u2014creating an immediate collision hazard. The truck failed to respond to throttle input, depriving me of predictable acceleration and propulsion when I needed it most to match the speed of oncoming traffic.I believe this incident is directly related to the well-documented 10R80 CDF clutch-cylinder sleeve defect. Ford\u2019s own technical documentation acknowledges that axial movement of this sleeve causes internal hydraulic leaks, leading to erratic shifting, slipping, and sudden losses of propulsion.This is fundamentally a safety defect, not a minor quality issue. An unexpected loss of power while merging or traveling at highway speeds places occupants at extreme risk of a rear-end collision. Because I have personally experienced this terrifying failure, I request that NHTSA open a formal investigation into the Ford 10R80 CDF clutch sleeve defect before it results in severe injuries or fatalities. Owners should not have to wait for a catastrophic transmission failure to receive a remedy.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11754224,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/24/2026","dateComplaintFiled":"08/01/2026","vin":"1FTEW1EG0JF","components":"POWER TRAIN","summary":"Truck will flare on lower gears of the 10 speed transmission. The 10R80 to be exact. The CDF drum was engineered incorrectly and ford has made an updated part but they didn\u2019t make it till 2023. So that leaves years 17\u2019-22 to have transmission problems and catastrophic transmission failures because of a bad design. It\u2019s very dangerous for a transmission to lose power on the roads and or react in a way that can make you lose control of vehicle. Ford has acknowledged the issue but not for the affected years. People have spent millions out of pocket and or if they had warranty coverage they spent have spent lots of unnecessary time with vehicles in and out of dealers and shops.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11754225,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/24/2026","dateComplaintFiled":"08/01/2026","vin":"1FTEW1EG0JF","components":"POWER TRAIN","summary":"Truck will flare on lower gears of the 10 speed transmission. The 10R80 to be exact. The CDF drum was engineered incorrectly and ford has made an updated part but they didn\u2019t make it till 2023. So that leaves years 17\u2019-22 to have transmission problems and catastrophic transmission failures because of a bad design. It\u2019s very dangerous for a transmission to lose power on the roads and or react in a way that can make you lose control of vehicle. Ford has acknowledged the issue but not for the affected years. People have spent millions out of pocket and or if they had warranty coverage they spent have spent lots of unnecessary time with vehicles in and out of dealers and shops.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11754087,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/23/2024","dateComplaintFiled":"07/31/2026","vin":"1FTFW1E52JK","components":"POWER TRAIN","summary":"Shifts from a high gear to a low gear at high speeds. Locks up back tires and is very unsafe. Revs up over 7000rpm in low gears and then shoots me forward. Have almost had several accidents due to these issues. Less than 60000 miles on truck. Feels very unsafe to me, my passengers and others around me when driving. Out of warranty specs.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11753459,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/29/2026","dateComplaintFiled":"07/29/2026","vin":"1FTFW1EG5JF","components":"EXTERIOR LIGHTING","summary":"The OEM LED headlights will not adjust, causing excessive glare to on coming drivers. This issue is 300 times worse than the miniscule amount of light that the daytime running lights emit, but somehow the running lights get a recall, but the headlight adjusters do not!    I'm completely flabbergasted at such an absurd and unjust oversite to such and important issue, please record this protest in the appropriate file, thanks. I constantly get offended drivers flashing their lights at me.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11753223,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/07/2025","dateComplaintFiled":"07/28/2026","vin":"1FTEX1EPXJK","components":"UNKNOWN OR OTHER","summary":"Transmission stopped gearing into 2nd gear because of known transmission issues with 2018 F150\u2019s. This happened before 60,000 miles on the truck, but was outside of warranty because was not reported until after the 5 year mark. Causes truck to jerk and transmission to deteriorate.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11752609,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/24/2026","dateComplaintFiled":"07/24/2026","vin":"1FTEW1EG0JK","components":"POWER TRAIN,ELECTRICAL SYSTEM,ENGINE","summary":"This vehicle has been into the Ford dealer multiple times for transmission slipping type issues. From before the 60,000 mile powertrain warranty ended and after. The dealer said the only thing needed was an update and reset. Today a different Ford dealer has informed me that during the transmission flush, there are tiny specks and slivers of metal.   The engine issue in regard to cam phaser repair recall/customer service bulletin has been leaking due to issues with proper sealant.  The rear camera goes out and screen turns white at times.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11751536,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/15/2026","dateComplaintFiled":"07/20/2026","vin":"1FTEW1EG8JF","components":"POWER TRAIN","summary":"Approximately four months ago, my truck started shifting hard going into second gear, then it quickly became jerky shifting in other gears with slippage, dangerous hesitation and engagement problems. It was so bad that I was almost rear-ended 3 times. Then the hesitation happened more often and a few times lost all power to transmission, and I had to stop in moving traffic for the transmission to find a gear. Very dangerous situation! A few weeks later, sudden downshifts for no reason were happening. I am the second owner of this truck that had 24,000 miles when I purchased it, and now it only has 49,500 miles with major transmission issues that are unsafe for me and my passengers, and the vehicles around me. The Ford dealer in my area has had my truck for a week, and nobody has called me, only making things worse.    Hesitation or delayed engagement  Sudden downshifts  Clunking noises  Occasional loss of power","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11750770,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/10/2026","dateComplaintFiled":"07/16/2026","vin":"1FTFW1EG4JF","components":"POWER TRAIN","summary":"The vehicle has gotten stuck in 7th gear before, it also has almost completely stopped, wouldn't accelerate and shifted down and up. It is not drivable now with only 58500 miles on it.  I am afraid to drive it by myself and I would never take my family anywhere in it as it poses a safety hazard / danger.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11749654,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/08/2026","dateComplaintFiled":"07/10/2026","vin":"1FTEX1EP7JK","components":"POWER TRAIN,VEHICLE SPEED CONTROL,ENGINE","summary":"COMPONENT; likely the transmission SAFETY revs went to almost zero on highway.  Transmission seemed to stop the truck. Then intermittent on and off transmission.  Seriously struggled to get the truck off the highway momentarily no ability to control speed: then on and off with the acceleration.  Very scary! sudden drop in speed on the highway could have caused an accident with no brake lights on Problem been reproduced: Not to my knowledge.  its at a dealer now.  Not safe to drive BEEN INSPECTED:  At dealer now Prior warning - lamps etc:  NONE WHATSOEVER  Oil lamp came on, then the check engine light came on well after the initial scare.","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11745829,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/22/2025","dateComplaintFiled":"06/23/2026","vin":"1FTEW1EG5JK","components":"POWER TRAIN","summary":"Subject: Safety Defect Complaint \u2013 Sudden 10R80 Transmission Failure in 2018 Ford F-150 Dear NHTSA, I am reporting a serious safety issue with my 2018 Ford F-150 equipped with the 10R80 10-speed automatic transmission. The transmission failed completely at only 93,000 miles, well before Ford\u2019s first recommended fluid change at 150,000 miles. While driving, the transmission suddenly shifted from 3rd gear directly to 7th gear, skipping intermediates. This caused severe loss of power (\u201cgutless\u201d) or abrupt deceleration nearly to a halt. The erratic behavior created multiple dangerous close calls in traffic. I was able to get it to a Ford dealer. They confirmed total transmission failure and referenced a Technical Service Bulletin identifying a known component (CDF clutch drum/hub) that commonly fails due to excessive heat and inadequate durability. Replacement was quoted at approximately $10,000. I contacted Ford Customer Service, described the safety risk of sudden unpredictable shifts, cited the known defect in their technical documentation, and requested assistance. Ford declined any support or remedy. This premature failure, combined with erratic shifting and loss of vehicle control, poses a clear risk of crashes. I urge NHTSA to investigate the 10R80 transmission issues in 2017\u20132020 F-150s and require Ford to issue a recall or extended remedies to protect public safety. Thank you for your attention. I have provided repair records, dealer notes, and further details below. Sincerely, [XXX] VIN: [XXX] Phone: [XXX] Email: [XXX]  Date: 6/22/2026 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11745268,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/06/2025","dateComplaintFiled":"06/19/2026","vin":"1FTEW1E5XJF","components":"POWER TRAIN","summary":"Vehicle stalls, slams into lower gear causing truck to slam to a stop.  Vehicle will go into neutral and not change gears while going down the hwy at hwy speeds","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]},{"odiNumber":11732044,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/18/2026","dateComplaintFiled":"04/18/2026","vin":"1FTEW1CBXJK","components":"POWER TRAIN,ELECTRICAL SYSTEM,VEHICLE SPEED CONTROL","summary":"I was on Spencer street at the light about to cross on Saint rose park way. When the light turned green my truck wouldn\u2019t let me proceed and the it went into a low gear and make a lot of noise until I crossed and stoped at the Horizon ridge light. At the light I turned off the truck like I have done every time this had happened after ford said they did the recall but after they did the recall I\u2019ve been having all these issues. I turned the vehicle back on and put into into drive and it went into reverse I immediately pressed my brakes knowing there is a car behind me. Thankfully the guy saw the truck with the hazards and going into reverse he immediately went into the next lane. I couldn\u2019t move I was stalled. Had the shut the truck off again and then turn it back on and then I was able to go into drive and sit on the side of the road. Meanwhile I can smell like this burning smell. Now this had happened 2 days after they came out to supposedly fix the recall that was on the truck. I didn\u2019t work the next day after they came out to fit it at my job but driving home that day it drove sort of ok I felt a little lack of going into gear. When I went to work it did a hard jerk while driving like if the transmission was going to fall out. I parked at work for my 10 hour shift and when I went to go home I turned on my truck and out it into drive and it went into reverse. Thankfully I was in park and no cars was behind me. I called ford to tell them what had happened after they came and fix it and they told me it was not part of the recall. But yet when I looked up the recall when my insurance let me know if it people was saying they was having issues going into gears and possibly stalling. This is a serious matter and they keep brushing it off and telling me that I need to pay them to look at it. I don\u2019t feel I need to pay if it is their mistake. I took it to my warranty company and they tried to fix it and found nothing on their end. At this point I gor into almost 5accident","products":[{"type":"Vehicle","productYear":"2018","productMake":"FORD","productModel":"F-150","manufacturer":"Ford Motor Company"}]}]}