{"count":198,"message":"Results returned successfully","results":[{"odiNumber":11600289,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/08/2024","dateComplaintFiled":"07/08/2024","vin":"YV1RS61T842","components":"ELECTRICAL SYSTEM,AIR BAGS,ENGINE","summary":"2004 VOLVO S60 PURCHASED THE CAR USED IN SEPT 04.  On 7/8/24 STRANDED AT 7-11 CAR WOULDN'T START. ACTING AS IF THERE WAS POWER LOSS, AC WENT OFF, BRAKE FAILURE LIGHT ON PANEL, POWER WINDOWS AND LOCKS DID NOT WORK, TEMP 105 OUTSIDE , THEN DRIVER PANEL WENT BLACK., I WAS SCARED. ENGINE WOULDN'T START. FINALLY, AFTER WAITING 10 MINUTES...IT STARTED RUNNING BUT WAS SLUGGISH. RADIO WAS ON, POWER DOOR, LOCKS, AND WINDOWS, DID NOT WORK. CUT THE CAR OFF AND BACK ON, ALL POWER RETURNED, NOW CHECK ENGINE AND AIR BAG TROUBLE ON PANEL. CALLED VOLVO DEALER NEXT DAY NEAR MY HOME, THEY CAN NOT SEE MY CAR TIL NEXT WEEK TUESDAY. CAN NOT ACCESS ENGINE BOX, MUST GO TO DEALER.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11495569,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/27/2022","dateComplaintFiled":"11/30/2022","vin":"YV1RH59HX42","components":"FUEL/PROPULSION SYSTEM","summary":"Starting Sunday November 27 my car started dripping gasoline on the floor, on the driver side near the rear wheel. Immediately I took it to Volvo dealer Wynne in Hampton, VA. The service specialist told me there was not any existing recall for that issue and let me go. That night I put under the leak a flat pan. That night I collected one gallon in about 8 hours.  I called Volvo cars USA [XXX] explained me the car have been fixed for the campaign #09V483000 in September 14, 2010. I own the car since 2015. I asked her if the recall should be possible to do it again at no cost for me, because it falls under Safety due to the fact the car may get in fire due to the leak of gas. She asked me to go back again to Wynne Volvo dealer and tell to the service specialist that I talked to them and if they wouldn't repair my car I could open a case with Volvo Cars USA. The service specialist told me I could leave the car for inspection, but I would be responsible for at least $180 to get and estimate, but never said that they would fix it under the safety recall number 09V483000 for vehicles sold or registered in the states with hot climate like Virginia. The recall started in January 15, 2010. It covers the fuel pump that can develop cracks in the fuel pump flange. The technician said the repair they did under the recall was replacing an O-Ring gasket only not the fuel pump. The person I talked to in Service is [XXX] with Title Service Advisor. Phone number [XXX].  I called again today Wednesday November 30, 2022 to Volvo Cars USA they said they can not promise to wave the repair because they need first that I pay $180 for a car diagnostic of the issue.   They would probably accept to pay part of the total charge but they would be doing it at good will.  I don't have $180 to pay upfront for a safety recall that it didn't last but only 12 years.  The Safety recall is valid as long as the car is in service, it doesn't matter if I am or not the first owner.  INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11441285,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/01/2021","dateComplaintFiled":"11/22/2021","vin":"YV1RS53DX42","components":"ELECTRICAL SYSTEM","summary":"The contact owns a 2004 Volvo S60. The contact stated that while operating the vehicle, the instrument panel would not illuminate or operate. During the failure, the fuel gauge, speedometer, odometer, and other information was unavailable to the driver. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 157,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11437725,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/20/2020","dateComplaintFiled":"10/21/2021","vin":"YV1RS64A342","components":"AIR BAGS,FUEL/PROPULSION SYSTEM","summary":"RECALL AIRBAGS- FUEL GAUGE GOES UP AND DOWN NEVER REGISTERS CORRECTLY","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11406424,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/07/2021","dateComplaintFiled":"04/05/2021","vin":"YV1RH59H042","components":"SEATS","summary":"DRIVING  HOME FROM CHURCH,, SMOKE STARTED COMING FROM THE DRIVERS SEAT,FROM THE HEATED SEAT. BURNED A HOLE THRU THE LEATHER . WAS ABLE TO TURN OFF THE SWITCH AND PUT SOME SNOW INTO THE GOLF SIZE HOLE AND PULLED THE FUSE TO THE ELECT HEAT SWITCH. NO FURTHER DAMAGE WAS NOTICED .CITY STREET. THE HOLE IS ABOUT 11/2 IN BELOW  LEFT SIDE BEADING AND CLOSER TO FRONT OF SEAT. LEATHER SEAT IN VERY GOOD CODITION AND NON SMOKER. GARAGE KEEP.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11400135,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/01/2020","dateComplaintFiled":"03/10/2021","vin":"YV1RS64A142","components":"SEAT BELTS","summary":"YES MY PASSENGER SIDE SEAT BELT JUST RANDOMLY LOCKED UP. MY CAR HAS NEVER BEEN IN ANY CRASHES I DIDN'T STOP SHORT FOR IT TO LOCK UP. I WENT TO PUT IT ON AND IT WOULD ONLY PULL HALF WAY OUT AND THEN WHEN IT WENT BACK IT IT STUCK. IT WON'T COME OUT AT ALL AT ALL NOW. I CAN'T PASS INSPECTION WITHOUT IT WORKING.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11364098,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"10/02/2020","dateComplaintFiled":"10/13/2020","vin":"YV1RS61T242","components":"AIR BAGS,STRUCTURE","summary":"MY SON WAS IN A SIDE IMPACT COLLISION ON THE PASSENGER SIDE OF HIS 2004 VOLVO S60. HE WAS IN A RURAL AREA AND EITHER DIDN'T SEE THE ONCOMING CAR OR MISSED HIS STOP SIGN AND THE ONCOMING DRIVER WAS UNABLE TO STOP. THE OTHER DRIVER IS UNINJURED BUT MY SON IN SEVERELY INJURED WITH A GRADE 3 DAI HEAD INJURY. HE WAS WEARING HIS SEAT BELT. THE SIDE AIRBAGS DEPLOYED BUT NOT THE ONE IN THE STEERING WHEEL. IN AN EMAIL VOLVO TOLD ME THIS IS HOW THE AIRBAGS ARE DESIGNED AND THAT THE DRIVER AIRBAGS WILL NOT DEPLOY ON SIDE IMPACT. IF THAT IS CORRECT INFORMATION, THIS NEEDS TO CHANGE. THE ONLY SIGNIFICANT INJURY MY SON HAS IS WHERE HIS HEAD HIT THE STEERING WHEEL, IF THAT AIRBAG HAD DEPLOYED HIS INJURIES WOULD HAVE POTENTIALLY BEEN MUCH LESS. THE AIRBAGS ARE ALREADY THERE, I DON'T UNDERSTAND WHY THEY CAN'T JUST DEPLOY ON ANY SIGNIFICANT IMPACT. I WILL INCLUDE PICTURES.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11317095,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/03/2020","dateComplaintFiled":"03/09/2020","vin":"YV1RS61T742","components":"SERVICE BRAKES, AIR,AIR BAGS","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED WHILE ATTEMPTING TO MAKE A LEFT TURN, ANOTHER VEHICLE INTERSECTED HER LINE CAUSING IMPACT TO THE FRONT DRIVER'S SIDE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT STATED THAT THE ABS WARNING LIGHT WAS ILLUMINATED PRIOR TO THE ACCIDENT. THE CONTACT STATED NO ONE SUSTAINED INJURIES OR SOUGHT MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE VEHICLE WAS TOWED TO AN IMPOUND LOT. THE VEHICLE FAILURE HAD NOT BEEN DIAGNOSED OR REPAIRED BY A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 162,000. *LN*JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11144780,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/01/2018","dateComplaintFiled":"11/01/2018","vin":"YV1RS61T042","components":"ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE STATIONARY, THE ENGINE CAUGHT FIRE. THE CONTACT STATED THAT SMOKE ENTERED INTO THE CABIN OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND OPENED THE HOOD, AND THE ENGINE WAS SURROUNDED BY FLAMES. A POLICE OR FIRE DEPARTMENT REPORT WAS NOT FILED. AN INDEPENDENT MECHANIC EXTINGUISHED THE FIRE. THERE WERE NO INJURIES SUSTAINED. A DEALER WAS NOT MADE AWARE OF THE FIRE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FIRE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11064892,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"01/01/2018","dateComplaintFiled":"01/25/2018","vin":"YV1RH52Y142","components":"SEATS","summary":"HEATED SEAT SHORTED WHEN TURNED ON ON DRIVERS SIDE AND BURNED ME WHILE DRIVING.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11042866,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/30/2017","dateComplaintFiled":"11/03/2017","vin":"YV1RS61T142","components":"ENGINE","summary":"CAR IS VOLVO S60 2004 TRIM 2.4 4 DOOR SEDAN FWD HAS 90317 MILES ON IT.   FROM LAST FEW WEEKS  WHEN I AM DRIVING VEHICLE IT STARTS LOSING POWER  AND A WARNING COME TRY SLOW DOWN OR SHIFT UP AND MY CHECK ENGINE LIGHT STARTED BLINKING. THIS HAPPENED 4 TIMES IN LAST 1 WEEK AS THE RESULT I NEED TO PULL MY CAR TO SAFE PLACE AND RESTART THAT AND THEN IT RUNS BETTER.   THIS HAS REALLY PUT ME IN DANGER TO MYSELF AND OTHER PEOPLE ON ROAD. I AM SCARE OF DRIVING THE CAR IN MULTIPLE LANE ROADS IN OTHER LANES. I AM NOW DRIVING IT ON RIGHT LANE ONLY SO THAT KEEP MYSELF AND OTHER PEOPLE SAFE FOR QUICK PULL OVER IF NEEDED.   CHECK ENGINE GIVES ME CODE P0171 AND P0300. I WENT ON LINE AND FOLLOWED ADVICE AND   CHANGED SPARK PLUGS, IGNITION COILS AND ALSO OXYGEN SENSOR BUT NO DIFFERENCE.     STILL CAR DID SAME THING WHEN I WAS DRIVING WITH MY FAMILY. I WENT ON LINE AND SAW THAT MANY PEOPLE HAVE THAT ISSUE WITH VOLVO S60 OF THIS YEAR AND MODEL AND STRUGGLING.   I THINK THIS IS SOME VOLVO S 60 2004 MODEL RECALL ISSUE AS IT IS CREATING ACCIDENTAL HAZARD TO THE OWNER OF THE CAR AND THE OTHER TRAFFIC.     DR TAKYAR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11034151,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/15/2017","dateComplaintFiled":"10/17/2017","vin":"YV1RS59V542","components":"STEERING,ENGINE,FUEL/PROPULSION SYSTEM","summary":"IN STOP AND GO TRAFFIC, MY FOOT WAS ON THE BRAKE TO SLOW DOWN. I TOOK MY FOOT OFF THE BRAKE AND STEPPED ON THE ACCELERATOR AS TRAFFIC MOVED AGAIN, THERE WAS NO RESPONSE TO MY FOOT ON THE GAS PEDAL. THE FUEL TANK, WHICH I HAD JUST FILLED 10 MILES BEFORE, SHOWED AS EMPTY ON THE FUEL GAGE. I WAS VERY, VERY SLOWLY ROLLING FORWARD WITH RESIDUAL MOMENTUM AND MY STEERING WASN'T WORKING. THERE WAS JUST ENOUGH PLAY IN THE WHEEL AND FORWARD MOMENTUM TO AIM AND ARRIVE AT THE SHOULDER OF THE HIGHWAY. THIS WAS ON RTE 156 IN MONTEREY COUNTY, CALIFORNIA,  WHERE VERY DANGEROUS ACCIDENTS HAPPEN ALL THE TIME. CAR HAD TO BE TOWED AND THE DEALERSHIP HAS BEEN UNABLE TO REPLICATE FAILURE. IT WAS OUTRAGEOUSLY DANGEROUS AND I WAS ALONE WITH MY 11-YEAR-OLD CHILD. SO FRIGHTENING!!!","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11023797,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/08/2017","dateComplaintFiled":"09/16/2017","vin":"YV1RS61T142","components":"FUEL/PROPULSION SYSTEM","summary":"ENGINE STALLS....MULTIPLE TIMES","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11006743,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/07/2017","dateComplaintFiled":"07/21/2017","vin":"YV1RS59V142","components":"ELECTRICAL SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED AND WAS PULLED OVER TO THE SIDE OF THE ROAD. THE VEHICLE WAS RESTARTED AND THERE WERE NO WARNING INDICATORS ILLUMINATED. THE FAILURE RECURRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11004724,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/12/2017","dateComplaintFiled":"07/12/2017","vin":"YV1RH59H742","components":"STEERING,FUEL/PROPULSION SYSTEM","summary":"I JUST RECENTLY WENT TO A DEALER FOR A GAS FUEL LEAK. THEY NOTICED A CRACK IN THE HOLDER. THE MECHANIC ALSO ASKED ME TO CHECK FOR A RECALL BEFORE FIXING DUE TO THIS BEING A COMMON PROBLEM WITH SOME VOLVOS. I AM ALSO NOTICING THERE IS A POWERSTEERING LEAKAGE SOMEWHERE BECAUSE IM CONSTANTLY PUTTING IN POWERSTEERING. PLEASE TAKE MY COMPLAINT IN CONSIDERATION DUE TO IT BEING LIFE THREATING AND I HAVE CHILDREN WHO I HAVE TO CARRY AROUND IN THAT VEHICLE. IF ITS A DEFECTIVE EQUITMENT ON VOLVO IM ASKING FOR IMMEDIATE REPLACEMENT. FOR SAFETY","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":11001876,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/16/2017","dateComplaintFiled":"06/28/2017","vin":"YV1RS61T442","components":"ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE ENGINE STARTED TO HESITATE AND STALLED. THE CONTACT COASTED TO THE SIDE OF THE ROAD AND WAITED FOR APPROXIMATELY THREE MINUTES AND RESTARTED THE VEHICLE. THE CONTACT DROVE THE VEHICLE TO M.P.L.  AUTOMOTIVE LACONIA NEW HAMPSHIRE (INDEPENDENT MECHANIC). THE VEHICLE WAS DIAGNOSED WITH A FUEL RAIL PRESSURE SENSOR NEEDING REPLACEMENT AND ALSO ADVISED THE CONTACT OF NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLANT). THE CONTACT CALLED LOVERING VOLVO MEREDITH NEW HAMPSHIRE WAS ADVISED THAT THE VIN WAS PART OF THE RECALL. THE VEHICLE WAS NOT REPAIRED AS OF YET. THE APPROXIMATE FAILURE MILEAGE WAS 158,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10915204,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/11/2016","dateComplaintFiled":"10/11/2016","vin":"YV1RS61T942","components":"FUEL/PROPULSION SYSTEM","summary":"GASOLINE FILL OVERFLOWS FREQUENTLY WHEN PUTTING IN FUEL, REGARDLESS OF AMOUNT OF FUEL ALREADY IN THE TANK.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10882802,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/02/2015","dateComplaintFiled":"07/05/2016","vin":"YV1RS59V042","components":"ELECTRICAL SYSTEM,ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, RESTARTED THE VEHICLE, AND RESUMED DRIVING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10875002,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/18/2016","dateComplaintFiled":"06/18/2016","vin":"YV1RS64A042","components":"ENGINE,FUEL/PROPULSION SYSTEM","summary":"CAR STALLED WHILST BREAKING","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10818605,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/06/2016","dateComplaintFiled":"01/07/2016","vin":"YV1RH59H642","components":"FUEL/PROPULSION SYSTEM","summary":"FUEL PUMP LEAKED. SMELL GAS. SCARED IT MAY CATCH FIRE. EXPENSIVE REPAIR. VOLVO IS REFUSING TO HONOR RECALL BECAUSE (1) VEHICLE PURCHASED IN NJ (THOUGH HAS SPENT LIFE IN VA) AND (2) WORK DONE AT NON-VOLVO MECHANIC. DUE TO THE SEVERITY OF THE ISSUE, I TOOK IT TO THE NEAREST MECHANIC RATHER THAN RISK DRIVING IT TO DEALER AND HAVING IT CATCH FIRE.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10808882,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/15/2015","dateComplaintFiled":"12/07/2015","vin":"YV1RS61T142","components":"ENGINE,FUEL/PROPULSION SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL RAIL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10807716,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/31/2015","dateComplaintFiled":"12/01/2015","vin":"YV1RS64A042","components":"FUEL/PROPULSION SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING 65 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO BE DIAGNOSED AT THE DEALER. THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10778030,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/10/2015","dateComplaintFiled":"09/28/2015","vin":"YV1RS59V242","components":"FUEL/PROPULSION SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHEN TURNING THE KEY INTO THE IGNITION SWITCH, THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10748225,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/10/2015","dateComplaintFiled":"08/12/2015","vin":"YV1RS64A942","components":"ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE STALLED ON MULTIPLE OCCASIONS WHILE DRIVING. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10703247,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/24/2014","dateComplaintFiled":"04/01/2015","vin":"YV1RS59V742","components":"FUEL/PROPULSION SYSTEM","summary":"MARCH 2014: I WAS TRAVELLING ON  A DIVIDED HIGHWAY AT 55 MPH AND THE CAR STALLED. MECHANIC STATED IT WAS THE FUEL PUMP.    MAR 2015 : THIS SAME EVENT OCCURRED AGAIN.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10691802,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/02/2015","dateComplaintFiled":"03/03/2015","vin":"YV1RS61T042","components":"SEATS","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE THE HEATED DRIVER SIDE SEAT WAS IN THE ON POSITION, A BURNING ODOR STARTED TO EMIT INSIDE THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACTED DISCOVERED A FLAME COMING FROM THE SIDE OF THE DRIVER SEAT. THE CONTACT INDICATED THAT THE FLAME SELF EXTINGUISHED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 107,000.    UPDATED 4/7/15*CN","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10661751,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/14/2014","dateComplaintFiled":"01/29/2015","vin":"","components":"ENGINE AND ENGINE COOLING","summary":"2004 VOLVO S60R, EXPERIENCE TOTAL ENGINE SHUTDOWN AT APPROXIMATELY 30 MPH THE VEHICLE JUST QUIT RUNNING.  CW  A DIAGNOSTIC INVESTIGATION BY THE DEALER, CONFIRMED THE FUEL PRESSURE SENSOR WAS AT FAULT. THE SENSOR WAS REPLACED AT A COST OF $ 420.69. THE CONSUMER INQUIRED ABOUT A RECALL. HOWEVER, HE WAS INFORMED HIS VEHICLE WAS NOT INCLUDED IN RECALL # 07V226000. *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10679079,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/20/2014","dateComplaintFiled":"01/27/2015","vin":"YV1RS61T142","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THE CHECK ENGINE LIGHT ILLUMINATED AND THE ENGINE SEIZED. THE FAILURE HAD RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT STATED THAT THE VEHICLE WAS EXHIBITING THE SAME FAILURES AS LISTED IN RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 187,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10677090,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/20/2015","dateComplaintFiled":"01/21/2015","vin":"YV1RS61T042","components":"STEERING,SERVICE BRAKES,ENGINE","summary":"THE 2.4L 2004 VOLVO S60 EXPERIENCES ERRATIC BEHAVIOR AND ENGINE FAILURE WHEN OPERATING MULTIPLE CONCURRENT ELECTRICAL SYSTEMS. WHEN THESE SYSTEMS (OPERATED WITHIN SPECIFIED GUIDELINES) ARE USED CONCURRENTLY THEY CAUSE THE FOLLOWING CONDITIONS: ENGINE FAILURE, LOSS OF POWER STEERING, LOSS OF BRAKES.     THE FOLLOWING IS A LIST OF ELECTRICAL CHANNELS THAT HAVE BEEN USED TO TRIGGER THE ENGINE FAILURE:     BRAKES,   INDICATOR LIGHTS (RIGHT OR LEFT)   HEATED SEATS (X2)   FRONT WINDSHIELD DEFROST    MULTIPLE S60 MODEL OWNERS HAVE REPORTED HAVING EXPERIENCED THIS SAME ENGINE FAILURE WHICH CANNOT BE DETECTED BY THE MANUFACTURES DIAGNOSTICS TEST. WHEN TESTED THE BATTERY, ALTERNATOR AND COMPUTER ALL PRESENT POSITIVE READ-OUTS.     HTTP://REPAIRPAL.COM/REPLACED-MAP-SENOR-AND-MAF-AIRFLOW-ENGINE-LIGHT-BACK-ON-HESITATE-STILL-CUT-OFF-321   HTTP://COMMUNITY.CARTALK.COM/DISCUSSION/2290017/VOLVO-S60-ENGINE-CUTS-OFF-WHILE-TURNING  HTTPS://ANSWERS.YAHOO.COM/QUESTION/INDEX?QID=20110502120739AA0TJSR    THIS IS A SERIOUS CONDITION THAT COULD RESULT IN A COLLISION OR EVEN DEATH. A RECALL ON THIS MODEL IS BEING IMMEDIATELY REQUESTED.     THANK YOU,     [XXX]       INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10681259,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/10/2013","dateComplaintFiled":"01/07/2015","vin":"YV1RH52YX42","components":"STEERING","summary":"I AM WRITING ABOUT WHAT MAY BE DESIGN FLAW WITH THE VOLVO S60R THAT HAS ME VERY CONCERNED. MY FRONT TIRES RUB ON THE BODY IN THE WHEEL WELL WHEN I TURN SHARPLY INTO A PARKING SPACE. I DON'T THINK IT SHOULD DO THAT BUT I'VE BEEN TOLD IT'S \"NORMAL\" AND THE CAR \"SETTLES\" AS IT GETS OLDER. SEVERAL OTHER VOLVO S60 OWNERS HAVE THIS SAME PROBLEM WHERE THE TIRES RUB ON THE BODY. PLEASE LOOK INTO THIS. I BELIEVE IT WILL CAUSE SERIOUS CONSEQUENCES IN AN EMERGENCY SITUATION AND IT'S WEARING DOWN THE EDGE OF THE TIRES PREMATURELY, WHICH MAY ALSO BE DANGEROUS.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10668747,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/28/2014","dateComplaintFiled":"12/29/2014","vin":"YV1RS61TX42","components":"ELECTRICAL SYSTEM,SEATS","summary":"DRIVER'S SIDE SEAT STARTED SMOKING WITHIN A FEW SECONDS OF STARTING THE VEHICLE WHILE BACKING OUT OF PARKING PLACE. SEAT HEATER WAS ON. IMMEDIATELY STOPPED AND TURNED OFF SEAT HEATER AND SMOKING STOPPED. QUARTER SIZE HOLE WAS BURNED INTO THE LEATHER SEAT BOTTOM ON THE DRIVER'S SIDE OUTSIDE PANEL. TOOK IT TO DARRELL WALTRIP VOLVO/SUBARU IN FRANKLIN, TN, AND THEY SAID IT WAS THE SEAT HEATER AND TOOK THE FUSE OUT. SAID IT WASN'T COVERED UNDER WARRANTY AND NO RECALL OUT. HOPE NO ONE HAS THIS PROBLEM DRIVING DOWN THE INTERSTATE.  BEST REGARDS AND THANKS FOR ALL YOUR HARD WORK, [XXX]    INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10667635,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/19/2014","dateComplaintFiled":"12/22/2014","vin":"","components":"FUEL/PROPULSION SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE PARKED, THE VEHICLE WAS LEAKING A LARGE AMOUNT OF FUEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 97,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10661589,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/01/2014","dateComplaintFiled":"12/02/2014","vin":"YV1RS61T942","components":"ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE STALLED.THE PROBLEM RECURRED NUMEROUS OF TIMES. THE VEHICLE WAS NOT TAKEN TO A DEALER NOR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10654041,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/03/2014","dateComplaintFiled":"11/10/2014","vin":"YV1RS59V542","components":"FUEL SYSTEM, GASOLINE","summary":"MY CAR WAS DYING ON THE HIGHWAY OR ON A REGULAR STREET ROAD.  ENDED UP BEING THE FUEL PRESSURE SENSOR WHICH IS ON THE RECALL LIST BUT DIDN'T COME UP FOR MY VIN.  I WAS DEALING WITH THIS FOR 6 MONTHS OR SO AND IT WAS VERY DANGEROUS.    I DON'T UNDERSTAND WHY MY CAR ISN'T ON THE RECALL LIST.  ANY HELP IS APPRECIATED.    [XXX]    INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10651699,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/24/2011","dateComplaintFiled":"10/31/2014","vin":"YV1RS61T242","components":"POWER TRAIN,ELECTRICAL SYSTEM","summary":"WHILE DRIVING, THE CAR JERKS VIOLENTLY -  THE SAME THING HAPPENS WHEN THE CAR IS IDLING (NO JERK, ONLY AN  \"CLICK\" SOUND). IT HAPPENS ANYTIME BUT SEEMS WORSE IN THE SUMMER BUT I THINK IT'S HOT-HEAT RELATED. THE OTHER ISSUES ARE RELATED:       -THE INTERIOR LIGHTS USUALLY COME ON      -THE INSTRUMENT PANEL GOES COMPLETELY BLANK/LIGHTS GO OFF/NO AVAILABLE EMERGENCY LIGHTS      -THE WINDSHIELD WIPERS MAKE ONE WIPE SOMETIMES      -THE \"REAR PASSENGER DOOR OPEN\" WARNING COMES ON      -THE \"BRAKE FAILURE STOP SAFELY\" WARNING COMES ON AND SOMETIMES \"CHECK ENGINE\" LIGHT COMES ON.     NOT ALL OF THESE SYMPTOMS OCCUR EACH TIME. THERE ARE MORE SEVERE AND LESS SEVERE INCIDENTS.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10651726,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/15/2014","dateComplaintFiled":"10/31/2014","vin":"","components":"FUEL SYSTEM, GASOLINE","summary":"TL*  THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE WOULD LOSE POWER AND EXHIBIT A SUDDEN INCREASE IN ENGINE RPMS BEFORE THE VEHICLE ACCELERATED. IN ADDITION, THE CHECK ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE DEALER DIAGNOSED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10630871,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/21/2014","dateComplaintFiled":"09/04/2014","vin":"YV1RS61TX42","components":"ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED WHILE DRIVING 70 MPH, THE CHECK ENGINE LIGHT ILLUMINATED. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER HAS BEEN MADE AWARE OF THE PROBLEM AND STATED THE VIN WAS NOT INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS 108,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10610925,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/16/2014","dateComplaintFiled":"07/16/2014","vin":"YV1RS59V942","components":"FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL","summary":"LOSS ACCELERATION IN THE VEHICLE ON THE HIGHWAY AT 60 MPH.  THE CAR WOULD NOT SPEED UP AND CONTINUE TO SLOW DOWN BUT NEVER CAME TO A FULL STOP.  I WAS NOT ABLE TO GO PASS 40 MPH IN THE CAR AND ACCELERATION WAS SLOW. FIRST TIME IT HAPPEN, THE DEALER SAID THROTTLE BODY AND OIL COLLECTION SYSTEM NEEDED TO BE REPLACED.  I REPLACED BOTH.  IT HAPPENS AGAIN, TOOK IT TO A DIFFERENT PERSON, THE MECHANIC SAID FUEL CONTROL NEEDED TO BE REPLACED.  I REPLACED THAT.  IT HAPPEN THE THIRD TIME AND TOOK IT TO DEALER AND HE INFORMED ME THE SPARK PLUGS.  I REPLACED THAT.  NOW, THE PROBLEM IS STILL HAPPENING.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10609526,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/09/2014","dateComplaintFiled":"07/10/2014","vin":"YV1RS61TX42","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH ATTEMPTING TO COME TO A COMPLETE STOP, THE VEHICLE STALLED WITHOUT NOTICE. THE CONTACT MENTIONED ALL LIGHTS ON THE CONTROL PANEL ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO MADE THE CONTACT AWARE OF RECALL NHTSA CAMPAIGN NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 95,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10596307,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/19/2014","dateComplaintFiled":"06/05/2014","vin":"YV1RS61T742","components":"ELECTRICAL SYSTEM","summary":"CAR WAS IN PARK AND RUNNING WHEN ELECTRICAL WIRES TO THE WINDSHIELD WIPERS CAUGHT FIRE. THE BUNDLE OF WIRES ARE HOUSED IN A RUBBER TUBE. MY UNDERSTANDING IS RUBBER IS QUITE FIRE-RESISTANT.  THERE HAVE BEEN 5 RECALLS ON THIS MODEL, TWO WHICH WERE RELATED TO ELECTRICAL FIRES.  NEITHER APPLIED TO THIS PARTICULAR CAR FIRE.  LOCAL VOLVO DEALERSHIP WANTS NOTHING TO DO WITH THE SITUATION; THEY SEND US TO CORPORATE CUSTOMER SERVICE AND THEY, IN TURN SEND US BACK TO THE LOCAL DEALERSHIP .  SERVICE MANAGER SAID HE WAS NOT A KNOWLEDGEABLE FIRE INSPECTOR AND SUGGESTED THAT WE HIRE AN EXPERT IN THAT FIELD.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10588205,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/06/2014","dateComplaintFiled":"05/13/2014","vin":"","components":"FUEL/PROPULSION SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING A VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS RESTARTED AND FUNCTIONED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL PRESSURE SENSOR WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 127,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10574239,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/21/2014","dateComplaintFiled":"03/23/2014","vin":"YV1RH59H142","components":"FUEL SYSTEM, GASOLINE","summary":"I HAD MY CAR IN FOR SERVICE AT MY LOCAL VOLVO REPAIR SHOP AND ONE OF THE ITEMS I HAD THEM INVESTIGATE WAS A FUEL SMELL.  THEY TOLD ME THEY FOUND A CRACK AT FUEL PUMP SENDER RH SIDE.  THEY MENTIONED THAT THEY THOUGHT THERE WAS A RECALL FOR THIS SINCE THEY HAVE SEEN IT SEVERAL TIMES BEFORE AND THAT I SHOULD CONTACT MY VOLVO DEALER.  I JUST LOOKED ONLINE AND FOUND WHAT THEY WERE TALKING ABOUT BUT IT DOES NOT LIST THE STATE WHERE I PURCHASED THE VEHICLE AND RESIDE?  I AM THE ORIGINAL OWNER.  THE REPAIR SHOP DID CONTACT A LOCAL DEALER FOR ME AND THE DEALER TOLD THEM THAT THERE WAS NOT A RECALL?   I GUESS I WILL CONTACT SOME OTHER LOCAL DEALERS THIS WEEK AND SEE WHAT THEY SAY?  SEEMS LIKE COLORADO SHOULD HAVE BEEN ADDED TO THIS RECALL EVERY STATE NEAR US IS PART OF IT.  IF I CANT GET THIS REPAIRED UNDER THE RECALL WHAT SHOULD I DO TO MAKE IT HAPPEN?  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10563015,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/31/2014","dateComplaintFiled":"02/05/2014","vin":"YV1RS59VX42","components":"VEHICLE SPEED CONTROL,ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THERE WAS A SUDDEN LOSS OF ENGINE POWER WITHOUT WARNING. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY AND BODY GASKET NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 145,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10544288,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"09/08/2013","dateComplaintFiled":"09/18/2013","vin":"YV1RS59V542","components":"AIR BAGS,STRUCTURE,SERVICE BRAKES","summary":"I WAS DRIVING 35-40 MPH WHEN A VEHICLE 2 CARS AHEAD OF ME HAD TO MAKE A QUICK STOP. I DID NOT SEE THIS HAPPEN IN TIME, SLAMMED ON MY BRAKES AND CONSEQUENTLY SMASHED INTO THE BACK OF THE CAR IN FRONT OF ME, WHO THEN HIT THE CAR IN FRONT OF HIM. I TOTALED MY CAR. THE PASSENGER AIR BAG DEPLOYED AND FILLED MY CAR WITH SMOKE (OR WHATEVER THAT IS) HOWEVER, THE DRIVER AIR BAG DID NOT DEPLOY. I WAS RUSHED TO A TRAUMA CENTER AND MY INJURIES INCLUDE MY BACK, NECK AND I LOST A TOOTH FROM MY FACE HITTING THE STEERING WHEEL. MY CHEST AND LEGS ARE COVERED IN BRUISES FROM THE SEAT BELT. I AM VERY LUCKY, HOWEVER, I DO NOT LIKE TO THINK OF WHAT COULD HAVE OCCURRED IF I WAS AT A HIGH SPEED AND ON THE FWY. AND THE AIR BAG DID NOT DEPLOY BECAUSE IT WAS DEFECTIVE, AND PERHAPS IT WAS NOT DESIGNED TO GO OFF IN THIS PARTICULAR INCIDENT? I HIT HEAD ON, NO LOGICAL REASON TO THINK THE PASSENGER AIRBAG GOING OFF AS IT DID, BUT NOT MINE OR DRIVER SIDE.  *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10536822,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/26/2013","dateComplaintFiled":"08/22/2013","vin":"","components":"VEHICLE SPEED CONTROL,ENGINE,FUEL/PROPULSION SYSTEM","summary":"CHECK ENGINE LIGHT CAME ON AND CAR LOST POWER WHILE DRIVING AT HIGHWAY SPEEDS. IT WOULD NOT ACCELERATE AND DISPLAYED THE MESSAGE \"REDUCED ENGINE PERFORMANCE\". DEALER INDICATED IT WAS A CRACKED INTERCOOLER HOSE AND THAT CAUSED THE ISSUE. IT WAS REPLACE AND AFTER ABOUT TWO MONTHS THE SAME SYMPTOMS HAPPENED. IT WAS THEN DIAGNOSED AS A BAD ELECTRONIC THROTTLE BODY. THAT WAS REPLACED AND THE SAME SYMPTOMS HAPPENED WITHIN TWO MONTHS AGAIN. THE CAR NOW DOES NOT ACCELERATE MORE THAN 10 MPH. THE NEXT DIAGNOSIS WAS TO REPLACE THE COMPLETE ENGINE WIRING HARNESS. THE CAR IS UNSAFE TO DRIVE BECAUSE IT STALL OR DECELERATE FROM HIGHWAY SPEEDS WITH NO NOTICE. IT IS VERY SIMILAR TO A RECALL FOR MODEL YEARS UP TO 2002.   *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10533665,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/19/2013","dateComplaintFiled":"08/05/2013","vin":"YV1RS61T242","components":"POWER TRAIN","summary":"WHILE DRIVING 45 MILES PER HOUR AND ABOUT TO GET ON THE ON RAMP ON TO I-10.  CAR LOST ALL ACCELERATION AND CAME TO A COMPLETE STOP.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10531592,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/02/2013","dateComplaintFiled":"07/24/2013","vin":"YV1RS61T342","components":"FUEL SYSTEM, GASOLINE,ENGINE","summary":"DRIVING HOME AFTER PURCHASING THE CAR (YEAH), I WAS TURNING INTO A PARKING LOT, SO MY SPEED WAS DESCENDING AND THE CAR STALLED. I WROTE IT OFF AS MY FAULT BECAUSE IT DID NOT HAPPEN AGAIN UNTIL 3 MONTHS LATER. WITHIN THE PAST 3 WEEKS THE CAR HAS STALLED WHILE IN MOTION APPROX. 6 TIMES. VOLVO STATED THE RECALLED PART FOR THIS ISSUE WAS REPLACED IN 2009. I NOTIFIED THE DEALER AND HAVE A APPOINTMENT FOR REPAIR, AT MY EXPENSE BECAUSE IT WAS ALREADY REPLACED. MEANWHILE I WILL NOT DRIVE THE CAR DUE TO THE LACK OF SAFETY. WISH I WOULD HAVE RESEARCHED THE CAR MODEL BEFORE PURCHASE.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10521856,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/10/2013","dateComplaintFiled":"06/26/2013","vin":"YV1RS59V424","components":"FUEL/PROPULSION SYSTEM","summary":"THE CAR HAD FUEL PUMP REPLACED ON 06/30/11 AND AGAIN (UNDER PARTS WARRANTY) AFTER BEING TOWED ON 05/14/13. ON JUNE 10, 2013 THE CAR HAD TO BE TOWED TO DEALER AGAIN WITH FUEL SUPPLY ISSUES. AFTER MUCH ANALYSIS, IT WAS CONCLUDED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE PRICE QUOTED FOR THE PART WAS $2447 AND LABOR $1400. THE FUEL PUMP APPARENTLY HAS AN INNER CONNECTOR SEAL (OR RING AND CLIP) THAT IS INTEGRAL TO THE TANK (CANNOT BE REPLACE SEPARATELY) THAT WAS POPPING LOOSE UNDER PRESSURE. AFTER MUCH DEBATE WITH VOLVO OF NORTH AMERICA, THEY GOT APPROVAL TO GIVE ME THE PART AT HALF PRICE--STILL $1223 PLUS AROUND $900 LABOR. IN DISCUSSING THIS WITH THE SHOP FOREMAN, HE HAD TALKED TO VOLVO REGIONAL PEOPLE ONE THE LOOKOUT FOR FLAWS. THEY WERE AWARE OF THIS PROBLEM, AND ALTHOUGH IT WAS RARE IT HAD HAPPENED ON SEVERAL OCCASIONS TO METAL TALKS THAT ARE 'CALIFORNIA' SPECS. ALTHOUGH VOLVO IS AWARE OF THE PROBLEM, THEY HAVE NOT NOTIFIED OWNERS OR DONE A RECALL BUT ARE REQUIRING THOSE WITH THE DEFECTIVE PART TO DISCOVER IT AND PAY FOR REPAIRS ON THEIR OWN. I THINK VOLVO SHOULD REFUND MY REPAIR COSTS AND NOTIFY OTHER OWNERS WHO HAVE THE SAME FUEL TANK.   *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10520078,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/14/2013","dateComplaintFiled":"06/17/2013","vin":"YV1RS59V642","components":"FUEL SYSTEM, GASOLINE,VEHICLE SPEED CONTROL","summary":"WHILE DRIVING 70 MPH, CAR LOST ACCELERATION AND STALLED WITHOUT WARNING.  IF I WOULD HAVE BEEN REAR ENDED GOING AT THIS SPEED I COULD HAVE LOST MY LIFE.  CHECK ENGINE LIGHT CAME ON AND ALL CODES ARE ASSOCIATED WITH THE 181 RECALL.  CALLED VOLVO AND VOLVO STATED THAT THIS VIN NUMBER WAS NOT PART OF THE RECALL YET I AM EXPERIENCING THE SAME EXACT PROBLEM AND HAVE THE SAME EXACT ENGINE CODES WHEN RUNNING A DIAGNOSTICS TEST ASSOCIATED WITH THIS RECALL.   *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10520117,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/15/2013","dateComplaintFiled":"06/17/2013","vin":"YV1RS59V642","components":"ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE STALLED AND PRIOR TO THE FAILURE THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. UPON RESTARTING, THE VEHICLE IT BEGAN TO FUNCTION NORMALLY. THE FAILURE RECURRED ON TWO  OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING WHO STATED THE TROUBLE CODES DETECTED A DEFECT WITH THE FUEL PRESSURE SENSOR AND ENGINE CONTROL MODULE. NHTSA RECALL CAMPAIGN ID NUMBER 07V2260000 (ENGINE AND ENGINE COOLING) WAS ASSOCIATED WITH THE FAILURE; HOWEVER, THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10514563,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/04/2013","dateComplaintFiled":"05/31/2013","vin":"YV1RS61T942","components":"FUEL/PROPULSION SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AS SOON AS THE ENGINE WAS STARTED. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC, WHO ADVISED THE CONTACT THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10505660,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/08/2012","dateComplaintFiled":"04/09/2013","vin":"YV1RS59V942","components":"ENGINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE RESTARTED FIVE MINUTES LATER AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS CONTRIBUTED TO THE FUEL PRESSURE SENSOR. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING). THE VIN WAS INELIGIBLE UNDER THE RECALL AND THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10500970,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/26/2013","dateComplaintFiled":"03/01/2013","vin":"","components":"SEATS","summary":"THE DRIVER SEAT OVERHEATED, APPARENTLY FROM A MALFUNCTIONING SEAT WARMER, CAUSING COMBUSTION. THE FIRE BURNED THROUGH THE SEAT PADDING, OUTER LEATHER COVERING, AND THE DRIVER'S CLOTHING. IT BURNED INTO A WALLET IN THE DRIVER'S BACK POCKET, WHICH PROTECTED THE DRIVER FROM A BURN. THE BURN HOLE IN THE SEAT IS ABOUT THE SIZE OF A NICKEL. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10496698,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/01/2013","dateComplaintFiled":"02/07/2013","vin":"YV1RH59H842","components":"ELECTRICAL SYSTEM","summary":"PURCHASED THIS CAR IN 2010 WITH 51,000 MILES.  SHORTLY AFTER PURCHASE CHECK ENGINE LIGHT CAME ON WITH SERVICE ENGINE SOON MESSAGE.  CAR WORKED FINE.  THEN BRAKE FAILURE MESSAGE CAME ON, BRAKES WORKED FINE.  TOOK VEHICLE TO VOLVO DEALERSHIP AND THEY FOUND A WAY TO \"RESET\" SYSTEM.  GO IN TRUNK, REMOVE BLACK BATTERY CABLE, TOUCH IT TO RED BATTERY CABLE FOR APPROX 10 SECONDS AND THE SYSTEM WILL.  WE'VE RESET THE SYSTEM COUNTLESS TIMES AND IT CONTINUES TO BE A PROBLEM.  ABOUT 3 MONTHS AGO ALL GAUGES WOULD QUIT WORKING AND CAR WOULD RANDOMLY BRAKE AT ABOUT 45 MPH.  PLUS AFTER COMING TO STOP, CAR WOULD BARELY MOVE BUT AFTER IT GOT GOING IT WOULD BE FINE.  RESET SYSTEM AND IT WORKED FOR ABOUT 3 MILES AND HAPPEN AGAIN.  VOLVO MECHANIC FOUND AWD (DEM) CONTROL MODULE FAILURE.  REPLACED THIS AT $1500 FOR THE PART AND AFTER 50 MILES, GAUGES STILL WORK, NO RANDOM BRAKING AND ACCELERATION IS NORMAL. BUT....SERVICE ENGINE MESSAGE AND CHECK ENGINE LIGHT BACK ON.  WAS TOLD THAT ALL MODULES RELATE TO EACH AND IF ONE IS OUT IT CAN AFFECT THE OTHERS.  AT ABOUT $1500 PER MODULE, IT IS COST PROHIBITIVE TO REPLACE ALL THESE, 6 TO BE EXACT.  VOLVO NEEDS TO RECALL THESE VEHICLES AND REPLACE THESE MODULES.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10495231,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/26/2013","dateComplaintFiled":"01/30/2013","vin":"YV1RS61T042","components":"SEATS","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT HE ACTIVATED THE HEATED SEATS AND AFTER A MATTER OF MINUTES, SMOKE BELLOWED FROM THE SIDE OF THE DRIVER'S SEAT. THE SEAT WARMER WAS DEACTIVATED AND THE CONTACT NOTICED THAT A ONE INCH HOLE HAD BEEN BURNED INTO THE SEAT. THE VEHICLE HAD NOT BEEN DIAGNOSED BY A MECHANIC. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 300,000.   UPDATED 2/12/13 *CN","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10493519,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/19/2013","dateComplaintFiled":"01/19/2013","vin":"YV1RS61T542","components":"SEATS","summary":"JUST LEAVING MY GARAGE, WE SMELLED SOMETHING AND IMMEDIATELY SAW SMOKE COMING FROM THE LEFT SIDE OF THE DRIVER SEAT.  THE SEAT WARMER WAS ON.  WE TURNED THE WARMER OFF AND OPENED THE DOORS.  THE ODOR AND SMOKE DISSIPATED BUT THERE IS A 1-1/2\" HOLE BURNED IN THE LEATHER.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10487931,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/01/2011","dateComplaintFiled":"12/10/2012","vin":"YV1RS61T742","components":"POWER TRAIN,ENGINE","summary":"APPROXIMATE A MONTH LATER AFTER I BROUGHT 2004 VOLVO S60 AT DEC 2011, WHEN I WAS DRIVING IN FREEWAY TO POST OFFICE, WHAT A SUDDEN, THE ENGINE STALLED WITHOUT WARNING,  I PRESS THE ACCELERATE PEDAL, BUT IT WAS NOT RESPONSE, BUT THE CAR STILL HV A LITTLE MOMENTUM, THEN IT TURN IT TO THE CORNER AND THE CAR WAS STOPPED. I TURN OFF THE KEY AND RESTART THE CAR AGAIN, IT WORKED.AFTER A YEAR, THE PROBLEM COME BACK AGAIN AND THE FREQUENCY  BECOME MORE, UP TIL DEC, 2012, 3 MORE TIMES  SAME PROBLEM INCURRED. IT WAS SCARY.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10482320,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/26/2012","dateComplaintFiled":"10/26/2012","vin":"YV1RH59H242","components":"ENGINE","summary":"WHILE DRIVING @ APPROXIMATELY 40 MPH THE VEHICLE MENTIONED ABOVE LOSS POWER AND STALLED, RESTART THE CAR AND AGAIN IT STALLED. DRIVER WAS ABLE TO DRIVE HOME AND PARKED THE CAR.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10481300,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/11/2011","dateComplaintFiled":"10/21/2012","vin":"YV1RH52Y042","components":"PARKING BRAKE,SERVICE BRAKES","summary":"GOOD AFTERNOON,    WE HAVE EXPERIENCED A CATASTROPHIC FAILURE OF THE EMERGENCY BRAKE, WHEREBY THE BRAKE LINING OF THE E-BRAKE IS OF AN \"ORGANIC\" COMPOUND AND ACCORDING TO THE VOLVO TECHNICIAN \"SWELLS\" WHEN IT GETS WET, CAUSING THE E-BRAKE TO LOCK-UP.  MY BRIDE WAS IN OUR NEIGHBORHOOD WHEN THIS OCCURRED, CAUSING THE ENTIRE BRAKING ASSEMBLY AND ASSOCIATED PARTS TO BE RIPPED AND BUSTED LOOSE.  VOLVO CHARGED US $2100 IN PARTS AND LABOR TO \"FIX\" THIS.  VOLVO TECHS DID SAY THAT THIS HAPPENS ALOT, BUT ALOT AT SPEED (FASTER THAN 25MPH).  CAN YOU IMAGINE THIS E-BRAKE LOCK-UP AT HIGHWAY SPEEDS.  HOW FREQUENTLY HAS THIS HAPPENED?  I HAVE PICTURES OF THE AFFECTED PARTS. THIS IS TOTALLY UNSAFE AND VOLVO KNOWS ABOUT IT.   *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10480682,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/16/2012","dateComplaintFiled":"10/16/2012","vin":"YV1RS61T242","components":"FUEL/PROPULSION SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE TRAVELING 30 MPH THE INSTRUMENT PANEL BEGAN TO ILLUMINATE THEN THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED TO PROCEED TO THE CONTACT'S DESTINATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS FOUND THAT THE FUEL INJECTOR HAD FAILED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V483000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP). THE FAILURE AND CURRENT MILEAGE WAS 86,100.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10467551,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/24/2012","dateComplaintFiled":"07/24/2012","vin":"YV1RH52Y342","components":"STEERING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60R. THE CONTACT WAS TRAVELING 12 MPH WHEN THE FRONT PASSENGER LOWER CONTROL ARM DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VIN FAILED TO QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER:04V029000 (STEERING:LINKAGES). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 135,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10463663,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/16/2008","dateComplaintFiled":"06/30/2012","vin":"YV1RS59V342","components":"ENGINE","summary":"THE VEHICLE ON SEVERAL OCCASIONS WILL COMPLETELY SHUT OFF WHILE IN THE MIDDLE OF DRIVING. I HAVE TAKEN IT TO SEVERAL MECHANICS AND WAS ADVISED THAT THEY CANNOT FIND ANYTHING WRONG WITH IT. I HAVE HAD THIS HAPPEN WHILE DRIVING ON THE EXPRESSWAY AT OVER 70 MPH AND LOCAL AT 35 MPH. I HAVE TO IMMEDIATELY SHIFT TO NEUTRAL AND TURN THE CAR BACK ON. IT IS EXTREMELY SCARY. I HAVE BEEN LUCKY THAT THERE HAS NEVER BEEN ANYONE BEHIND ME, BUT IF SOMEONE IS BEHIND ME AND IT HAPPENS AGAIN, THERE WILL DEFINITELY BE AN ACCIDENT. THIS HAS HAPPENED 8 TIMES NOW.   *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10463514,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/08/2012","dateComplaintFiled":"06/29/2012","vin":"YV1RS59V842","components":"ELECTRICAL SYSTEM","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WAS EXPERIENCING SEVERAL ELECTRICAL FAILURES. THE REAR DOOR INDICATOR WAS ILLUMINATED, THE VEHICLE WAS EXHIBITING HESITATION, THE STEERING WAS HARD TO TURN AND THE INTERIOR LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE BRAKE, SPARK PLUGS AND AIR FILTER WAS REPLACED HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO EXPERIENCE THE ELECTRICAL FAILURES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000 AND THE CURRENT MILEAGE WAS 120,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10460300,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/01/2012","dateComplaintFiled":"06/01/2012","vin":"YV1RS59V042","components":"ENGINE","summary":"THE PCV \"FLAME TRAP\" HAS CLOGGED IN MY 2004 VOLVO S60 WITH ONLY 41,000 MILES AND AS IT TURNS OUT, THIS IS A $1200 JOB. I WOULDN'T BE SO DISMAYED HAD I NOT DISCOVERED THAT THIS IS AN EXTREMELY PREVALENT PROBLEM AND THAT IT IS GUARANTEED TO HAPPEN TO YOUR CAR PRIOR TO 100,000 MILES. THAT THERE IS NEARLY NO AMOUNT OF MAINTENANCE ONE CAN DO TO PREVENT THIS PROBLEM. THE WORST PART ABOUT THIS PROBLEM IS THAT IF IT'S NOT REPAIRED PROMPTLY, IT WILL LEAD TO OIL BURNING AND THE DAMAGING OF VARIOUS SEALS IN THE ENGINE WHICH WILL LEAD TO CATASTROPHIC ENGINE FAILURE. VOLVO HAS EXTENDED ITS WARRANTY COVERAGE FOR THIS PROBLEM ON ITS S40 MODEL CARS WHICH SHARE THE ENGINES IN THE S60, YET HAS NOT ACKNOWLEDGED THIS TO BE A MAJOR PROBLEM IN ITS S60 MODELS.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10459330,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/05/2011","dateComplaintFiled":"05/22/2012","vin":"YV1RS61T642","components":"STEERING,ELECTRICAL SYSTEM,ENGINE","summary":"WHEN TURNING A CORNER. I NOTICED THE CHECK ENGINE LIGHT WAS ON.  THE THIS HAPPENED A SECOND TIME A WEEK LATER, AND THEN SEVERAL ADDITIONAL TIMES. I TOOK THE CAR TO INDEPENDENT MECHANIC AND HE CHECKED IT OUT BUT COULDN'T DIAGNOSE THE PROBLEM. HE ONLY SPECULATED THAT IT COULD BE THE PVC BOX, BUT THAT THEY WERE NOT SURE IT WOULD FIX THE PROBLEM. THE CAR HAD APPROXIMATELY 100K AFTER THIS HAPPENED ABOUT EIGHT TIMES IN THE NEXT 3 MONTHS, I TOOK THE CAR TO VOLVO DEALER. THEY CHECKED IT OUT, AND TOLD ME IT MAY BE THE PVC BOX, BUT THEY WERE NOT SURE THIS WOULD FIX THE PROBLEM. I TOOK IT TO ANOTHER MECHANIC AND WHO SAID IT WAS THE CATALYTYIC CONVERTER. THIS PROBLEM HAS BEEN ONGOING FOR A YEAR. I TOOK THE CAR TO ANOTHER MECHANIC AND HE CHANGED THE SPARK PLUGS AND CABIN FILTER. HE TOLD ME TO TAKE THE CAR TO THE VOLVO DEALERSHIP/SERVICE TO HAVE THE COMPUTER RESET. HE SAID,  BECAUSE THE CAR LOOSES PRESSURE AND STALLS WHEN YOU MAKE A QUICK TURN. I CALLED VOLVO THEY SAID THIS WOULD FIX THE PROBLEM.   I TOOK THE CAR TO VOLVO TO GET AN OIL CHANGE. THEY TOLD ME THE CAR STALLED OUT ON THE MECHANIC 3 TIMES AND THE CHECK ENGIINE LIGHT WAS ON. THEY CHECKED THE CAR ON THE COMPUTER AND TOLD ME THE ENGINE COILS NEEDED REPLACING. THAT WAS THE PROBLEM.  I PAID FOR THE ENGINE COILS TO BE REPLACED AND SOME OTHER WORK WHICH TOTALED $1350.00. I PICKED THE CAR UP ON FRIDAY, ON MONDAY, WHILE TURNING A CORNER THE CAR STALLED OUT, NO POWER, NO STEERING, JUST ONBOARD LIGHTS. IT HAPPENED AGAIN ON TUESDAY MORNING.     I EXPERIENCED THIS PROBLEM WHEN THE CAR WAS UNDER RECALL. THE DEALERSHIP FIXED IT, BUT IT SEEMS AS THOUGH THIS PROBLEM IS OCCURING AGAIN. THIS IS DANGEROUS AND VOLVO SHOULD BE RESPONSIBLE AND FIX THESE CARS. THERE ARE SOME SERIOUS MECHANICAL/ENGINE PROBLEMS WITH THIS VEHICLE.  *TT","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10453769,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/27/2012","dateComplaintFiled":"04/02/2012","vin":"YV1RS61T642","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THE DRIVERS SPEED WAS 25 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CHECK ENGINE LIGHT ILLUMINATED PRIOR TO THE FAILURE; YET, THE VEHICLE RESTARTED AFTER THE FAILURE OCCURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 80,250.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10451468,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/17/2011","dateComplaintFiled":"03/13/2012","vin":"YV1RH59H442","components":"SERVICE BRAKES, HYDRAULIC,VEHICLE SPEED CONTROL","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT WAS DRIVING 25 MPH WITH CRUISE CONTROL ACTIVATED WHEN THE BRAKES WERE DEPRESSED BUT THE VEHICLE FAILED TO STOP.  THE CONTACT CRASHED INTO FIVE VEHICLES. THE CONTACT'S VEHICLE WAS DESTROYED. THE  POLICE WERE CONTACTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC AND THE MANUFACTURER WAS CONTACTED. UPDATED 04/16/12 *BF  THE CONSUMER STATED THE CRUISE CONTROL WAS NOT FUNCTIONING PROPERLY. THE THROTTLE REMAINED OPEN. UPDATED 04/25/12","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10450359,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/25/2012","dateComplaintFiled":"03/05/2012","vin":"YV1RS59V242","components":"ENGINE AND ENGINE COOLING","summary":"TL*  THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE DECELERATED WITHOUT WARNING AND STALLED.  THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING). THE DEALER WAS CONTACTED AND ADVISED THE CONTACT THAT THAT THEY WOULD REPAIR THE VEHICLE BY REPLACING THE FUEL PRESSURE SENSOR. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED TWICE. THE FAILURE MILEAGE WAS 94,000 AND THE CURRENT MILEAGE WAS 95,412.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10448374,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/22/2008","dateComplaintFiled":"02/17/2012","vin":"YV1RS59V542","components":"STEERING,ELECTRICAL SYSTEM","summary":"1/22/08 INSERTED KEY AND IT WOULD ONLY MOVE INTO THE FIRST POSITION ACTIVATING THE RADIO, LIGHTS, ETC.  UNABLE TO CONTINUE TO TURN KEY AND TURN ON AUTOMOBILE.  STEERING COLUMN LOCK ASSEMBLY FAILED, ALTHOUGH IT IS EXPECTED TO LAST THE LIFE OF THE CAR, LEAVING ME STRANDED AND WITHOUT A CAR FOR OVER A WEEK SINCE PART COMES FROM GERMANY.  4/17/12 SAME SYMPTOMS AND ONCE AGAIN I AM STRANDED UNEXPECTEDLY.  VOLVO DEALER REPORTS THIS HAPPENS OFTEN AND NEW DOUBLE PRICED PART MIGHT LAST LONGER.  THIS IS A DANGER DUE TO ITS SUDDEN COMPLETELY UNPREDICTABLE ONSET, INABILITY TO BE DRIVEN, AND LENGTH OF TIME THAT THE CAR IS UNABLE TO BE IN USE.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10447294,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/09/2012","dateComplaintFiled":"02/09/2012","vin":"YV1RS64A642","components":"ELECTRICAL SYSTEM,SEATS","summary":"LIKE MANY OTHERS WHO ARE ON VOLVO WEBSITES HAVE REPORTED I TOO HAD A FIRE ON THE DRIVERS SEAT LEFT SIDE DUE TO MY SEAT HEATER. I NOW HAVE A HALF DOLLAR SIZED HOLE IN THE SIDE OF MY SEAT. THE FIRST SIGN OF THIS WAS A SMELL AND THEN A LOT OF SMOKE. LUCKILY I WAS ABLE TO PULL OVER QUICKLY AND HAD A TOWEL HANDY TO SNUFF IT OUT, OTHERWISE I WOULD HAVE BURNED HANDS OR OTHER PARTS. I'VE BEEN A LIFELONG VOLVO OWNER, I HAVE TO SAY I'M SURPRISED VOLVO HASN'T AT LEAST WARNED THEIR DEALERS ABOUT THIS PROBLEM.  I DID SEE ANOTHER DRIVERS SEAT TOTALLY BLACKENED AND BURNT OUT LAST TIME I TOOK MY CAR IN, WAS AMAZED THAT IT COULD EVEN HAPPEN LET ALONE BE A COMMON OCCURRENCE. NOW AFTER SEARCHING ONLINE THIS IS A PREVALENT PROBLEM.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10444626,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/12/2012","dateComplaintFiled":"01/20/2012","vin":"YV1RS61T742","components":"ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM,EXTERIOR LIGHTING","summary":"WHEN TURNING A CORNER, THE ENGINE STOPPED, STEERING STOPPED WORKING AND LIGHTS ON DASHBOARD COME ON.  THIS HAPPENED A SECOND TIME TWO DAYS LATER.  TOOK TO INDEPENDENT MECHANIC AND HE CHECKED ALL WORK HE HAD DONE IN THE PAST PLUS CHECKED THE WHOLE CAR OUT AND HE COULD NOT FIND WHY THE CAR STOPPED.  TWO DAYS LATER THE CAR AGAIN STALLED OUT WHEN IN TRAFFIC - ENGINE STOPPED, STEERING STOPPED WORKING AND LIGHTS ON DASHBOARD CAME ON.  LAST TWO TIMES THIS HAPPENED I WAS DRIVING ON A STRAIGHT ROAD. THIS HAS HAPPENED 5 TIMES NOW IN THE LAST WEEK.   ALL TIMES ENGINE STOPPED WORKING, I WAS DRIVING BETWEEN 10 AND 40 MILES PER HOUR.  AFTER RESEARCHING THIS PROBLEM, I FOUND OUT THAT MY VEHICLE HAD BEEN RECALLED AND AT 53,333 MILES THE FUEL PRESSURE SENSOR WAS REPLACED BY THE DEALER.  NOW 42,000 MILES LATER IT APPEARS THAT IT IS ONCE AGAIN THE FUEL PRESSURE SENSOR.  THIS IS VERY DANGEROUS ESPECIALLY SINCE I DO A LOT OF HIGHWAY DRIVING AND ALSO LIVE IN AN AREA WHERE CHILDREN HAVE BEEN KNOW TO RUN OUT INTO THE STREET.  NOT ONLY IS THERE A POSSIBILITY OF A CAR ACCIDENT, BUT ALSO THE POSSIBILITY OF A CHILD BEING HIT IF I CANNOT TURN  THE CAR QUICKLY TO AVOID THE CHILD.  AT THIS POINT I AM AFRAID TO DRIVE THE CAR AND FELL VERY UNSAFE EVEN THOUGH VOLVOS ARE KNOW FOR THEIR SAFETY.  AFTER READING NUMEROUS REPORTS OF MANY PEOPLE HAVING THIS PROBLEM WITH THEIR 2004 S60 VOLVOS IT MAKES ME WONDER WHY VOLVO IS NOT CORRECTING THIS PROBLEM ON ALL 2004 VOLVO S60S THAT ARE HAVING THIS SAME PROBLEM.  MY MECHANIC IS CHECKING ON THIS PROBLEM AND WILL REPLACE NEXT WEEK IF THIS IS THE REAL ISSUE.      SOMETIMES DOORS LOCK FOR NO REASON AT ALL.    ALSO I HAVE HAD TO REPLACE THE REAR LIGHTS ON THIS VEHICLE SEVERAL TIMES.  SEEMS MUCH MORE THAN NORMAL.  *TT","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10432885,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/15/2011","dateComplaintFiled":"10/26/2011","vin":"YV1RS59V942","components":"FUEL SYSTEM, GASOLINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE WOULD FAIL TO ACCELERATE WHEN DRIVING AT VARIOUS SPEEDS. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD INTERMITTENTLY STALL DURING THE FAILURE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND AN INDEPENDENT REPAIR SHOP TO HAVE THE FAILURE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FAILURE WAS DUE TO THE FUEL PRESSURE SYSTEM. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V483000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE FAILURE MILEAGE WAS 67,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10430398,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/08/2010","dateComplaintFiled":"10/16/2011","vin":"YV1RS61T642","components":"ENGINE AND ENGINE COOLING","summary":"AT ANY GIVEN TIME THE VEHICLE STALLS. I LOOSE ALL POWER AND HAVE TO RESTART THE CAR. I'VE TAKEN THE CAR TO THE DEALER THEY DON'T GIVE ME AN ANSWER. FINALLY THEY GAVE ME A LIST OF ITEMS THAT SAY MAY BE THE PROBLEM, BUT ARE NOT SURE IT'S THE PROBLEM. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10428692,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/04/2011","dateComplaintFiled":"10/04/2011","vin":"YV1RS64A842","components":"FUEL SYSTEM, GASOLINE","summary":"I OWN A 2004 VOLVO S60. I RECENTLY FOUND OUT THAT THERE IS A RECALL ON MY VEHICLE AFTER MY MECHANIC TOLD ME MY CHECK ENGINE LIGHT WAS DUE TO THIS RECALL. VOLVO SAYS THERE IS NO SUCH RECALL AT FIRST, BUT UPON CALLING THE CUSTOMER SERVICE NUMBER I FOUND OUT THAT THERE IS. HOWEVER, THEY SAY IT IS VIN SPECIFIC AND THAT MINE IS NOT COVERED. MY MECHANIC SAYS THAT THIS NEEDS TO BE TAKEN CARE OF, FOR THIS PROBLEM CAN CAUSE MY ENGINE TO STALL OUT AT ANYTIME AND CAUSE MY STEERING WHEEL TO JERK AROUND ON THE HIGHWAY. TO ME, THIS IS A HUGE PROBLEM, SOUNDS LIKE THAT IT COULD POTENTIALLY KILL ME ON THE ROAD. HOW CAN SOMETHING THAT CAN BE THIS POTENTIALLY DANGEROUS NOT BE VOLVOS RESPONSIBILITY TO FIX? JUST BECAUSE MY VIN NUMBER IS DIFFERENT DOES NOT MEAN THE PROBLEM IS ANY LESS SERIOUS, THOUGH VOLVO SEEMS TO THINK IT IS. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10421346,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/27/2011","dateComplaintFiled":"08/24/2011","vin":"YV1RS61TX42","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, THE ENGINE SUDDENLY STALLED FOR ONE SECOND. THERE WAS NO PRIOR WARNING AND THE CONTACT WAS ABLE TO CONTINUE DRIVING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS AND THEY INFORMED THE CONTACT THAT THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATELY FAILURE MILEAGE WAS 78,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10418181,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/02/2011","dateComplaintFiled":"08/09/2011","vin":"YV1RS59V742","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60.  THE CONTACT WAS DRIVING 60 MPH WITH CRUISE CONTROL ACTIVATED WHEN THE VEHICLE BEGAN TO LOSE POWER ABNORMALLY. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC. THE MECHANIC PERFORMED A DIAGNOSTIC TEST AND ADVISED THAT THE FUEL PRESSURE SENSOR WAS DEFECTIVE. THE MECHANIC REFERENCED NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) AND ADVISED THAT THE RECALL WAS ASSOCIATED WITH THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT HOWEVER, THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 92,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10418049,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/01/2011","dateComplaintFiled":"08/08/2011","vin":"YV1RS59V842","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING 45 MPH, THE CONTACT STATED THAT AT ANY GIVEN TIME, THE VEHICLE WOULD STALL, THE STEERING WHEEL WOULD LOCK  AND THE BRAKE PEDAL WOULD FAIL.  THE CONTACT RESEARCHED THE FAILURE AND FOUND THAT THERE WAS A NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) RECALL.  THE CONTACT NOTIFIED THE DEALER, AND THE DEALER TOLD THE CONTACT THAT THE VIN WAS NOT APART OF THE RECALL.  THE MANUFACTURER WAS NOT CONTACTED AND THE FAILURE WAS NOT REPAIRED.  THE FAILURE MILEAGE WAS 65,700 AND THE CURRENT MILEAGE WAS 66,000.... UPDATED 01/04/12  *BF  THE CONSUMER STATED THE PROBLEM WAS REPAIRED AT A COST OF $1000.00 UPDATED 01/12/12","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10417667,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/02/2011","dateComplaintFiled":"08/05/2011","vin":"YV1RS61T942","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING AND NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. AFTER THE FAILURE, THE CONTACT FOUND THE RECALL ASSOCIATED WITH THE NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING). THIS RECALL ADDRESSED A FUEL PRESSURE SENSOR PROBLEM, WHICH WAS THE CAUSE OF THE CURRENT FAILURE. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE AND CURRENT MILEAGES WERE 103,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10416626,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/29/2011","dateComplaintFiled":"08/02/2011","vin":"YV1RS61T842","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING APPROXIMATELY 55 MPH AND DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE DECELERATED AND STALLED WITHOUT WARNING. THE CONTACT PLACED THE VEHICLE IN PARK AND TURNED THE KEY IN THE IGNITION TO RESTART THE ENGINE. AFTER THE VEHICLE WAS RESTARTED, THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIANS STATED THAT THE FUEL PRESSURE SENSOR WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) THAT COULD POSSIBLY HAVE BEEN RELATED TO THE FAILURE YET THE DEALER INFORMED THE CONTACT THE VIN WAS NOT INCLUDED IN THE RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 81,500.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10415341,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/01/2011","dateComplaintFiled":"07/27/2011","vin":"YV1RS64AX42","components":"FUEL SYSTEM, GASOLINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, SHE NOTICED THAT THERE WAS AN ODOR OF GASOLINE. A FUEL LEAK WAS ALSO DISCOVERED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HER THAT THE SEAM OF THE FUEL TANK WAS ROTTED AND NEEDED TO BE REPLACED. THE ENTIRE FUEL TANK WAS REPLCACED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10411848,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/18/2011","dateComplaintFiled":"07/11/2011","vin":"YV1RS61T342","components":"FUEL SYSTEM, GASOLINE","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING 75 MPH, THE CONTACT STATED THAT SHE APPLIED PRESSURE TO THE ACCELERATOR PEDAL; HOWEVER, SHE WAS UNABLE TO ACCELERATE WHEN SHE NOTICED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED.  THE DEALER HAD NOT BEEN NOTIFIED.  THE MANUFACTURER WAS AWARE OF THE FAILURE.  THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INSPECTED THE VEHICLE AND INFORMED THE CONTACT THAT THE FUEL REGULATOR PRESSURE SENSOR HAD FAILED AND NEEDED TO BE REPLACED.  NO REPAIRS WERE PERFORMED.  THE CURRENT MILEAGE WAS 73,000.  THE APPROXIMATE FAILURE MILEAGE WAS 72,600.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10406252,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/13/2011","dateComplaintFiled":"06/14/2011","vin":"YV1RS59V742","components":"ENGINE AND ENGINE COOLING","summary":"NUMEROUS TIMES VEHICLE HAS STALLED SUDDENLY AT VARIOUS SPEEDS - ALL POWER IS LOST AND THE CHECK ENGINE LIGHT IS ILLUMINATED.  VEHICLE WILL RESTART AFTER A FEW MINUTES. TAKEN TO LOCAL MECHANIC - UNABLE TO REPLICATE ISSUE. FOUND RECALL FOR 2004 VOLVO S60, BUT VEHICLE VIN NOT INCLUDED IN RECALL.  MILEAGE AT 55,000.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10398267,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/29/2011","dateComplaintFiled":"04/29/2011","vin":"YV1RH59H142","components":"ENGINE AND ENGINE COOLING,VEHICLE SPEED CONTROL","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT WAS DRIVING APPROXIMATELY 30 MPH WHEN THE VEHICLE ABNORMALLY ACCELERATED UNTIL CRASHING. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER BUT THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS REPAIRED FOR THE BODY DAMAGES. THE FAILURE AND CURRENT MILEAGE WAS 92,058.    UPDATED 05/26/11  *BF  THE CONSUMER STATED AS SHE MADE A TURN, THE VEHICLE TOOK OFF AT A VERY HIGH SPEED. THE VEHICLE WENT FORM SIDE TO SIDE AS SHE TRIED VERY HARD TO BRAKE AND STEER AWAY FROM THE INCLINE ON THE RIGHT.  THIS ACTION CONTINUED FOR ABOUT 0.3 MILES, BEFORE THE VEHICLE AIR LIFTED AND THE RIGHT PASSENGER SIDE BETWEEN THE REAR DOOR AND REAR QUARTER PANEL HIT THE GUARDRAIL. THE VEHICLE THEN BOUNCED OFF THE GUARDRAIL, CROSSED THE STREET, JUMPED THE GUTTER AND LANDED ON ITS WHEELS IN A NEARBY FIELD, WHERE IT CAME TO A STOP.  WHEN SHE TRIED TO START THE VEHICLE, SHE KEPT IN THE LOWEST GEAR, WITH HER FOOT ON THE BRAKE AND A MESSAGE LIGHT ILLUMINATED STATING DO NOT DRIVE, COOLANT IS LOW. UPDATED 08/24/11","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10397241,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/25/2011","dateComplaintFiled":"04/24/2011","vin":"YV1RS61T142","components":"ENGINE AND ENGINE COOLING,EQUIPMENT","summary":"2004 VOLVO S60 STALLED SUDDENLY WHEN TURNING.  IT HAS  STALLED WHEN PULLING FROM A STOP SIGN. BOTH INCIDENTS OCCURRED AROUND WITH 100,000 MILES ON THE CAR. COMPLETE LOSS OF POWER, STEERING, AND BRAKING.  VEHICLE TAKEN TO DEALER AND WAS TOLD THERE WAS A PROBLEM WITH THE FUEL PRESSURE SENSOR.  THERE IS A RECALL FPS FOR THE SAME YEAR, MAKE AND MODEL AS MY CAR, HOWEVER, I WAS TOLD THAT MY VIN# IS NOT INCLUDED IN THE RECALL.  PROBLEM HAS YET TO BE FIXED.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Equipment","productYear":"9999","productMake":"FUEL PRESSURE GAUGE","productModel":"2659","manufacturer":"AUTO METER PRODUCTS, INC."}]},{"odiNumber":10396856,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/14/2011","dateComplaintFiled":"04/19/2011","vin":"YV1RS59V942","components":"POWER TRAIN","summary":"I WAS DRIVING MY 2004 VOLVO S60. THERE WERE NO ADVERSE DRIVING CONDITIONS, AND I WAS DRIVING NORMALLY. I WENT TO PUT MY S60 IN PARK, AND IT WOULD NOT GO PAST NEUTRAL INTO EITHER REVERSE OR PARK. MY S60 HAS A GEARTRONIC TRANSMISSION (GEARTRONIC IS ESSENTIALLY THE BRAND NAME OF THE VOLVO MANUMATIC TRANSMISSION. SOURCE:  HTTP://WWW.EHOW.COM/INFO_7784643_GEARTRONIC-TRANSMISSION.HTML#IXZZ1K1HJ4JPR)  THIS IS A SAFETY ISSUE BECAUSE OF THE FACT THAT IF I NEEDED TO GO INTO REVERSE I COULDN'T, AND BECAUSE I COULD NOT SHIFT INTO PARK AND THEREFORE COULD NOT REMOVE MY KEY FROM THE IGNITION. THERE WERE NO NOTICEABLE EVENTS LEADING UP TO THIS FAILURE OF THE GEARTRONIC TRANSMISSION SHIFT KNOB, BUT IT IS A VALID SAFETY ISSUE, AND MAY RESULT IN A RECALL IF THIS FAILURE OCCURS IN MORE VOLVOS WITH THE GEARTRONIC TRANSMISSION. ANY INFORMATION YOU CAN GATHER FROM VOLVO DEALERS AND OTHER REPUTABLE VOLVO SERVICE BUSINESSES CAN POTENTIALLY GATHER ENOUGH ISSUES WITH THE GEARTRONIC TRANSMISSION SHIFT KNOB TO ISSUE A RECALL.    THIS ISSUE, IF IT HAS OCCURRED OR DOES OCCUR IN OTHER VOLVOS WITH THE GEARTRONIC TRANSMISSION AND GEAR SHIFT KNOB, MAY CAUSE THE DRIVER TO NOT BE ABLE TO SHIFT INTO OR OUT OF CERTAIN GEARS, AND MAY RESULT IN THE CARS NOT BEING ABLE TO BE PUT INTO PARK. THIS COULD RESULT IN SAID VEHICLES ROLLING AFTER TURNED OFF. ALSO, THE KEY WILL NOT COME OUT OF SAID VEHICLES IF THEY ARE NOT ABLE TO BE SHIFTED INTO PARK.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10395299,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/30/2010","dateComplaintFiled":"04/08/2011","vin":"YV1RS59V242","components":"VEHICLE SPEED CONTROL","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60 . THE CONTACT STATED WHILE DRIVING ON THE HIGHWAY APPROXIMATELY 65 MPH, THE VEHICLE STALLED. HE MENTIONED THAT THE FAILURE OCCURRED SEVERAL TIMES PRIOR. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THE THROTTLE BODY NEEDED TO BE REPLACED. THE FUEL PRESSURE SENSOR ALSO HAD TO BE REPLACED UNDER NHTSA CAMPAIGN ID NUMBER:  07V226000  (ENGINE AND ENGINE COOLING ). THE MANUFACTURER WAS CONTACTED AND DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 55,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10393723,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/29/2011","dateComplaintFiled":"03/30/2011","vin":"YV1RS59V142","components":"ELECTRICAL SYSTEM","summary":"THIS IS WHAT IS HAPPENING TO ME WITH MY 2004 T2.5 S60 VOLVO. I CALLED VOLVO AND THEY SAID NO RECALLS YET I SEE THIS SAME THING HAPPENING TO OTHER, IT HAS TO BE A DEFECT WITH THE CAR. MY HAPPENS WHEN THE WEATHER GETS HOT HERE IN CALIFORNIA. I HAD NO PROBLEMS THIS WINTER, BUT YESTERDAY IT WAS IN THE MID TO HIGH 80?S AND THE PROBLEM HAPPENED AGAIN!  NO WARNING TO THE EVENTS. ON NUMEROUS OCCASIONS, THE CAR FEELS AS IF IT HAS HIT A LARGE OBJECT, TEMPORARILY LURCHES AND APPEARS TO MOMENTARILY STALL CREATING A TEMPORARY LOSS OF VEHICLE CONTROL. THIS IS FOLLOWED BY AN IMMEDIATE LOSS OF ALL INSTRUMENT GAUGES, AIR CONDITIONER, WINDOW CONTROLS AND DOOR LOCKS. THE FAN DID CONTINUE TO WORK. THE ABS WARNING LIGHT ALSO INDICATED AS WELL AS A WARNING THAT NO BRAKES FUNCTION EXISTED. THE SRS SERVICE AIR BAG URGENT INDICATION IS ILLUMINATED. ON TURNING THE CAR OFF AND RESTARTING(SOMETIMES THAT DOESN'T WORK, BUT IF I REMOVE THE BATTERY CABLE AND LET IT SET FOR A BIT AND PUT IT BACK ON THE CAR WILL START), THE FUNCTIONS OF THE CAR RETURN WITH EXCEPTION THAT THE SRS SERVICE AIR BAG URGENT INDICATION REMAINS. THIS PROBLEM CAN TAKE MONTHS TO REPEAT OR ONLY A MATTER OF MINUTES. IT SEEMS TO BE MORE PREVALENT IN HOT WEATHER.  I HAVE TAKEN IT TO DIFFERENT REPAIR PLACES AND THEY  TOO MANY CODES, RESET IT AND IT COMES BACK AGAIN. THIS HAS BEEN GOING ON FOR OVER THE PAST TWO YEARS.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10392822,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/24/2011","dateComplaintFiled":"03/24/2011","vin":"","components":"SEATS","summary":"BURNING PASSENGER SEAT IN 2004 VOLVO S60R.  WHILE DRIVING I SMELT A HORRIBLE BURNING SMELL AND SEEN SMOKE COMING FROM THE PASSENGER SEAT WHICH EVENTUALLY STARTED A FIRE. I TURNED OFF THE HEATED SEATS AND NOW HAVE A BURN ABOUT AN INCH IN DIAMETER. THIS IS VERY DANGEROUS AND SHOULD BE RECALLED IMMEDIATELY. THIS IS A SERIOUS SAFETY ISSUE THAT NEEDS TO BE ADDRESSED. NOT HAPPY WITH THIS AT ALL! GLAD NO ONE GOT HURT!  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10386096,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/01/2010","dateComplaintFiled":"03/01/2011","vin":"YV1RS64A942","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT WAS DRIVING 30 MPH UPHILL WHEN THE VEHICLE BEGAN TO LOSE POWER ABNORMALLY. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC. THE MECHANIC PERFORMED A DIAGNOSTIC TEST AND ADVISED THAT THE FUEL PRESSURE SENSOR WAS DEFECTIVE. THE MECHANIC REFERENCED NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) AND ADVISED THAT THE RECALL WAS ASSOCIATED WITH THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT HOWEVER, THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10380936,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/06/2011","dateComplaintFiled":"02/07/2011","vin":"YV1RS59V142","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING, THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE FAILURE WAS CAUSED BY THE FUEL PRESSURE SENSOR. THE CONTACT REFERENCED RECALL 07V226000 (ENGINE AND ENGINE COOLING) BUT WAS INFORMED BY THE MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED. THE CURRENT AND FAILURE MILEAGES WERE 65,983.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10381009,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/03/2011","dateComplaintFiled":"02/07/2011","vin":"YV1RS59V142","components":"FUEL SYSTEM, GASOLINE","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT WAS DRIVING 60 MPH WHEN THE VEHICLE LOST POWER AND STALLED. THE CONTACT STATED THAT THERE WAS NO WARNING PRIOR TO THE FAILURE. THE CONTACT WAITED 15 MINUTES AND RESTARTED THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE FUEL PRESSURE WAS THE CAUSE OF THE FAILURE. THE CONTACT REFERENCED RECALL 09V483000 (FUEL SYSTEM, GASOLINE: DELIVERY: FUEL PUMP) BUT WAS TOLD BY THE DEALER THAT THE VEHICLE WAS NOT INCLUDED. THE CURRENT AND FAILURE MILEAGES WERE 53,000.  UPDATED 04/07/11*LJ  THE CONSUMER STATED THE PROBLEM WAS THE FUEL PRESSURE SENSOR. THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED IN THE RECALL. UPDATED 04/08/11","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10380823,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/19/2010","dateComplaintFiled":"02/05/2011","vin":"YV1RH52Y742","components":"ENGINE AND ENGINE COOLING","summary":"WHEN I DRIVE MY MANUAL TRANSMISSION S60R VOLVO, AND I SHIFT I HEAR A LOUD THUD IN THE BACK OF THE CAR, I CHECKED EVERYTHING THAT COULD POSSIBLY BE MAKING THE NOISE AND SECURED IT,  IT BOTHERED ME SO MUCH I TOOK IT TO THE VOLVO DEALER AND THEY TOLD ME THAT IT WAS ACTUALLY BECAUSE OF THE SUSPENSION SOFTWARE AND THAT THERE WAS A RECALL FOR THIS, HOWEVER IT WAS NOT APPLICABLE FOR MY VIN.  HE SAID THIS WAS THE BEST GUESS HE COULD MAKE, I INFORMED HIM THAT IT ONLY MAKES THE NOISE IF YOU MAKE A PRETTY GENTLE SHIFT, BUT IT CAN HAPPEN AT ANY TIME.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10380824,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/19/2010","dateComplaintFiled":"02/05/2011","vin":"YV1RH52Y742","components":"SUSPENSION","summary":"WHEN I DRIVE MY MANUAL TRANSMISSION S60R VOLVO, AND I SHIFT I HEAR A LOUD THUD IN THE BACK OF THE CAR, I CHECKED EVERYTHING THAT COULD POSSIBLY BE MAKING THE NOISE AND SECURED IT,  IT BOTHERED ME SO MUCH I TOOK IT TO THE VOLVO DEALER AND THEY TOLD ME THAT IT WAS ACTUALLY BECAUSE OF THE SUSPENSION SOFTWARE AND THAT THERE WAS A RECALL FOR THIS, HOWEVER IT WAS NOT APPLICABLE FOR MY VIN.  HE SAID THIS WAS THE BEST GUESS HE COULD MAKE, I INFORMED HIM THAT IT ONLY MAKES THE NOISE IF YOU MAKE A PRETTY GENTAL SHIFT, BUT IT CAN HAPPEN AT ANY TIME.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10380825,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/15/2010","dateComplaintFiled":"02/05/2011","vin":"YV1RH52Y742","components":"ENGINE AND ENGINE COOLING","summary":"I DRIVE A VOLVO S60R AND WHEN I AM ACCELERATING I NOTICE THAT I HAVE A VERY LARGE LACK OF POWER GOING FROM 3000 TO 3500 RPM'S, THERE IS ALMOST NO INCREASE IN POWER.  I HAVE BROUGHT UP THE ISSUE WITH A VOLVO DEALER AND THEY INFORMED ME THAT THERE WAS A RECALL FOR THIS, BUT MY CAR FOR SOME REASON DID NOT GET THE RECALL.  HE SAID IT IS THE SAME ISSUE BUT THERE WAS NOTHING HE CAN DO ABOUT IT.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10378409,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/23/2011","dateComplaintFiled":"01/24/2011","vin":"","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE SUDDENLY STALLED. AFTER THE FAILURE, ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE WAS ABLE TO RESTART AFTER A COUPLE OF MINUTES OF WAITING. THE VEHICLE HAD NOT BEEN INSPECTED NOR HAD IT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 72,000. THE VIN WAS UNAVAILABLE.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10376877,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/01/2010","dateComplaintFiled":"01/16/2011","vin":"YV1RS61T142","components":"EQUIPMENT","summary":"2004 S60 VOLVO ALARM SYSTEM SERVICE REQUIRED. I'VE OWNED MORE THAN 8 DIFFERENT CARS OLDER THAN THIS CAR, AND THEY NEVER HAD ANY ISSUE WITH THE ALARM. IT SEEMS TO BE VERY COMMON TO REPLACE THE ALARM MODULE IN THIS VOLVO MODEL BECAUSE OF THE ACID LEAK FROM THE BATTERY THAT CAUSES A SHORT IN THE CIRCUIT. AND YES IT WILL HAPPEN AGAIN AFTER THE REPLACEMENT. WHAT A RIPOFF. *LN","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10376516,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/13/2010","dateComplaintFiled":"01/13/2011","vin":"YV1RH52Y442","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE","summary":"THE ENGINE LIGHT CAME ON IN MY 2004 VOLVO S60R. THE CAR WOULD LOOSE ACCELERATION AND ALSO STALLED. VOLVO SAID IT WAS THE FUEL PRESSURE SENSOR AND THAT IT HAD BEEN RECALLED BY VOLVO- RECALL # 07V226000. BUT THE VIN # OF MY CAR WAS NOT INCLUDED IN THE RECALL. IT WAS THE SAME PART THAT WAS RECALLED ON OTHER 2004 S60S. WHY NOT ON THE R AS WELL? *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10376515,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/11/2010","dateComplaintFiled":"01/13/2011","vin":"YV1RH52Y442","components":"ELECTRICAL SYSTEM","summary":"VOLVO S60R SEAT ISSUE. TURNED SEAT HEATER ON, FELT VERY WARM SENSATION ON MY LEFT HIP/LEG AFTER A FEW MINUTES. TURNED SEAT HEATER OFF AND GOT OUT OF CAR TO CHECK WHAT WAS HAPPENING. SEAT HEATER BURNED THROUGH THE LEATHER AND ALSO MY JEANS. IS THERE A RECALL/FIX? SEEMS EXTREMELY DANGEROUS. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10375581,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/06/2010","dateComplaintFiled":"01/11/2011","vin":"YV1RS59VX42","components":"FUEL SYSTEM, GASOLINE","summary":"TOOK VEHICLE TO A VOLVO DEALERSHIP FOR A REGULARLY SCHEDULED OIL CHANGE.  THE SERVICE ADVISOR REPORTED THAT THE FUEL PRESSURE SENSOR (FPS) IS A CRITICAL COMPONENT, THAT IT FAILED AND NEEDED TO BE REPLACED.  HE SAID THAT VOLVO WOULD PAY 50% FOR THE PART AND CHARGE ME THE WARRANTY LABOR RATE. THEY WOULD NOT TELL ME IN ADVANCE THE TOTAL COST.  AS I WAS LEAVING, ANOTHER SERVICE ADVISOR TOLD A PERSON OVER THE TELEPHONE THEY NEEDED A FUEL PRESSURE SENSOR AND WOULD GET 50% OFF.  A FEW DAYS LATER A FRIEND TOOK HER S40 TO THIS DEALER AND WAS TOLD SHE NEEDED A FUEL PRESSURE SENSOR TO FIX HER ACTUAL FUEL SYSTEM PROBLEM (IT DID NOT).    THE ODDS OF A PERSON LEARNING ABOUT 3 VOLVOS NEEDING FUEL PRESSURE SENSOR REPLACEMENTS IN THIS MANNER SEEMS PHENOMENAL.  AS SUCH, IT APPEARS THAT EITHER: 1) VOLVO'S FUEL PRESSURE SENSORS HAVE A HIGH FAULT RATE; 2) VOLVO UNDERSTATED THE CARS TO INCLUDE IN ITS RECALL CAMPAIGN NUMBER R181; 3) CARS INCLUDED IN THE RECALL CAMPAIGN ARE BEING CHARGED FOR THE REPAIR; OR 4) THE QUESTION OF HOW VOLVO IS / IS NOT MANAGING THE DEALER TO DETERMINE IF THERE IS A HIGH INCIDENCE OF FUEL PRESSURE SENSOR FAILURES ON THE CARS BEING SERVICED DURING THAT TIME PERIOD AND THE REASONS FOR THOSE FAILED FUEL PRESSURE SENSORS.    NHTSA SHOULD REQUIRE VOLVO TO SUPPLY STATISTICS AND RECORDS (PROBABLY A SIMPLE VOLVO DATABASE SEARCH) FOR ALL VEHICLES RECEIVING NEW FUEL PRESSURE SENSORS AND IDENTIFY WHETHER: 1) THE REPAIR WAS INCLUDED IN RECALL NUMBER R181; 2) THE NON-RECALL FPS CUSTOMER WAS CHARGED FOR THE REPAIR; 3) THE NON-RECALL FPS CUSTOMER WAS NOT CHARGED FOR THE REPAIR.  AND, FOR THOSE VEHICLES, THE NHTSA SHOULD REQUIRE VOLVO TO PROVIDE THE PLANT, PRODUCTION DATE, AND CHASSIS NUMBER. RUNNING THE REPORT IN MODEL NUMBER AND CHASSIS NUMBER ORDER (CHRONOLOGICAL ORDER) OF ALL CARS WITH FPS PROBLEM WOULD LIKELY AID THE NHTSA IN DETERMINING WHETHER THE EXTENT OF THE FPS PROBLEM AND ACCURACY OF THE VOLVO'S RECALL CAMPAIGN NUMBER R181.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10371941,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/01/2010","dateComplaintFiled":"12/21/2010","vin":"YV1RS59V842","components":"VEHICLE SPEED CONTROL","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING AT ANY SPEED, THE CONTACT STATED THAT THE VEHICLE WOULD MOVE INTO LIMP MODE, CAUSING THE VEHICLE TO STALL. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT DID NOT INFORM THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 96,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10371219,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":true,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/18/2010","dateComplaintFiled":"12/19/2010","vin":"YV1RH59H032","components":"SEATS","summary":"WHILE DRIVING VEHICLE NOTICED VERY STRONG BURNING SMELL. FELT BURNING SENSATION THROUGH SLACK LEG WHILE STILL DRIVING. NOTICED A HOLE HAD BURNED THROUGH LEATHER ON REAR LEFT SIDE OF DRIVERS SEAT. SMOKE WAS PUMPING OUT OF HOLE IN LEATHER (APPX 1/2-INCH ROUND) FROM SEAT PADDING. I IMMEDIATELY TURNED SEAT WARMER OFF AND THE BURNING STOPPED. AN HOUR LATER, I TURNED SEAT WARMER ON WHILE AUTO WAS RUNNING. SMOKE BEGAN COMING OUT OF SEAT HOLE WITHIN ABOUT 30-45 SECONDS. TURNED OFF SEAT WARMER IMMEDIATELY. BURNING STOPPED. VERY DANGEROUS SITUATION. INSIDE OF AUTO NOW STINKS OF BURNED PLASTIC/FOAM.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10366851,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/19/2010","dateComplaintFiled":"11/19/2010","vin":"YV1RS59VX42","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING 30 MPH THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENTAL PANEL. THE VEHICLE RESTARTED WITHIN A FEW MINUTES. THE VEHICLE WAS THEN INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT THE FUEL PUMP AND THE ENGINE COOLING SYSTEM HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10365777,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/15/2008","dateComplaintFiled":"11/15/2010","vin":"","components":"FUEL SYSTEM, GASOLINE,EXTERIOR LIGHTING","summary":"PURCHASED AUTO NEW. IT WOULD SEEM THAT I HAVE HAD SOME OF THE SAME PROBLEMS MENTIONED BY OTHERS. CAR STALLING ON HIGHWAY AT 65 MILES PER HOUR, TWICE, VERY SCARY. PULLED OFF AND RESTARTED. (FUEL PRESSURE SENSOR MALFUNCTION) SEEMS THERE IS A RECALL HOWEVER WHEN I INQUIRED MY VIN # WAS NOT INCLUDED. COSTLY REPAIR AS MUST PURCHASE PART FROM DEALER. DRIVER SIDE HEAD LAMP, LOW BEAM, HAS BEEN REPLACED SO OFTEN LOST TRACK, OVER HALF A DOZEN TIMES, IS OUT NOW! HAVE NEVER REPLACED PASSENGER SIDE LAMP! I POINT OUT THE OTHER S60'S I SEE ON THE ROAD WITH A HEADLAMP LIGHT OUT TO MY KIDS AS A GAME NOW.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10365136,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/25/2010","dateComplaintFiled":"11/09/2010","vin":"","components":"FUEL SYSTEM, GASOLINE","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WHILE THE CONTACT DECELERATED TO MAKE A TURN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE FUEL RAIL PRESSURE SENSOR WAS DEFECTIVE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 109,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10364959,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/05/2010","dateComplaintFiled":"11/08/2010","vin":"YV1RS59V342","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT WAS DRIVING 35 MPH WHEN THE VEHICLE ABNORMALLY SURGED FORWARD AND THEN STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AS IT RESUMED NORMAL OPERATION. THE FAILURE PERSISTED AND THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT INQUIRED WITH THE MANUFACTURER OF NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) BUT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 72,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10361233,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/01/2010","dateComplaintFiled":"10/19/2010","vin":"YV1RH52Y042","components":"FUEL SYSTEM, GASOLINE","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60R. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH, THE ENGINE COMPLETELY STALLED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE ENGINE RESTARTED AND THE VEHICLE BEGAN FUNCTIONING NORMALLY. THE FAILURE CONTINUED TO OCCUR SPORADICALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FUEL PUMP NEEDED TO BE REPLACED, AND ALSO ADVISED THE CONTACT OF NHTSA RECALL CAMPAIGN ID NUMBER 09V483000 (FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP). THE VEHICLE WAS TAKEN TO THE DEALER TO BE REPAIRED; HOWEVER, THE VOLVO MODEL YEAR 2004 S60R WAS NOT INCLUDED IN THE RECALL. THE 2004 VOLVO S60 WAS INCLUDED IN THE RECALL DEFECT. THE VEHICLE WAS BEING REPAIRED AT THE OWNER'S EXPENSE. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.       UPDATED 2/28/11 *CN  UPDATED 03/03/11*JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10359522,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/20/2010","dateComplaintFiled":"10/07/2010","vin":"YV1RH52Y642","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60R. WHILE DRIVING APPROXIMATELY 35-40 MPH, THE VEHICLE BEGAN JERKING AND SUDDENLY STALLED. THE CONTACT PULLED OVER AND RESTARTED THE VEHICLE WHICH FUNCTIONED PROPERLY. THE FAILURE OCCURRED TWICE AFTER THE INITIAL TIME. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE SENSOR NEEDED TO BE REPLACED. THE CONTACT REFERENCED RECALL 07V226000 (ENGINE AND ENGINE COOLING) BUT WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 49,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 52,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10357926,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/01/2010","dateComplaintFiled":"09/27/2010","vin":"YV1RS61T742","components":"FUEL SYSTEM, GASOLINE","summary":"MY CAR STALLED TWICE AT LOW SPEED, BOTH TIMES WAS ABLE TO RE-START IMMEDIATELY.  AFTER THE 2ND INCIDENT, THE CHECK ENGINE LIGHT ILLUMINATED WITH A GENERIC OBD-II CODE OF P0192.  ONLINE RESEARCH HAS FOUND THIS CODE RELATES TO THE  FAILURE OF THE VEHICLE'S FUEL PRESSURE SENSOR.  VOLVO HAS RECALL #R-181 IN PLACE BUT I AM TOLD BY VOLVO CARE THAT MY CAR IS EXCLUDED FROM ELIGIBILITY FOR THIS RECALL BASED ON THE CHASSIS NUMBER - DESPITE HAVING THE SAME ENGINE CODE (61) AND EXPERIENCING THE SAME ISSUE AS DESCRIBED IN THE VOLVO RECALL NOTICE.   I HAVE FOUND A NUMBER OF SIMILAR COMPLAINTS ON VARIOUS WEBSITE FORUMS AND EVEN THIS (NHTSA) WEBSITE.  IT WOULD SEEM TO ME THAT VOLVO MAY HAVE TO RE-VISIT THE CRITERIA FOR HOW THEY DETERMINED WHICH VEHICLES ARE AFFECTED BY THIS FAULTY FUEL PRESSURE SENSOR.  HAVING TO PAY $300+ OUT OF POCKET FOR A KNOWN FAULTY PRODUCT IS INSULTING. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10357341,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/16/2007","dateComplaintFiled":"09/24/2010","vin":"YV1RS61T642","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT ATTEMPTED A TURN WHEN THE VEHICLE INDEPENDENTLY DECELERATED AND STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE DEALER SUGGESTED THAT THE FUEL INJECTORS AND THROTTLE BODY BE CLEANED, WHICH WAS COMPLETED. THE FAILURE RECURRED WITHIN A FEW MONTHS WITH THE ILLUMINATION OF THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE VEHICLE WAS DIAGNOSED INDICATING THAT THE AIR PRESSURE WAS INACCURATE OR THERE WAS A FUEL LEAK. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE PROGRESSED. THE CONTACT INQUIRED WITH THE MANUFACTURER IN REGARDS TO NHTSA CAMPAIGN ID NUMBER: 07V226000 (ENGINE AND ENGINE COOLING) BUT WAS ADVISED THAT HER VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 79,245 AND THE CURRENT MILEAGE WAS APPROXIMATELY 116,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10356719,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/12/2010","dateComplaintFiled":"09/21/2010","vin":"YV1RS64A542","components":"STRUCTURE,LATCHES/LOCKS/LINKAGES","summary":"I HAVE A 2006 VOLVO S-60 AND THE INTERIOR DOOR PANEL ON PASSENGER SIDE FAILED WHICH LEADS TO THE PASSENGER NOT BEING ABLE TO EXIT THE VEHICLE. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10355590,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/10/2010","dateComplaintFiled":"09/14/2010","vin":"YV1RS59V542","components":"VEHICLE SPEED CONTROL","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60.  THE CONTACT STATED THAT THE CHECK ENGINE LIGHT WOULD ILLUMINATE SPORADICALLY FOLLOWED BY THE VEHICLE STALLING. THE FAILURE WOULD OCCUR MOST OFTEN WHEN DRIVING AT LOW SPEEDS. THE VEHICLE WAS TAKEN TO A LOCAL INDEPENDENT MECHANIC WHO ADVISED THE CONTACT THAT THE FUEL SENSOR WAS DEFECTIVE.  THE VEHICLE WAS NOT REPAIRED.  THE MANUFACTURER WAS CONTACTED BUT WOULD PROVIDE NO ASSISTANCE.  THE CURRENT AND FAILURE MILEAGE WAS 52,000. UPDATED 12/03/10. *LJ","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10353108,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/29/2010","dateComplaintFiled":"08/31/2010","vin":"YV1RS61T442","components":"ENGINE AND ENGINE COOLING","summary":"I HAVE A 2004 VOLVO S-60 WITH APPROXIMATELY 75,000 MILES ON IT.  IN THE PAST 6 WEEKS, THE CAR ENGINE HAS COMPLETELY DIED THREE SEPARATE TIMES - WITHOUT WARNING.  *TR    THE EMERGENCY HAZARD LIGHT STILL WORKED, THE FAN STILL BLOWS (NO A/C, JUST THE FAN), BUT OTHERWISE THERE IS NO POWER, NO BRAKES, NO STEERING, NO WARNING LIGHTS WHATSOEVER.  EACH TIME THIS HAS HAPPENED, IT HAS BEEN WHEN I AM DRIVING BETWEEN 40-55MPH.      WHEN THE CAR COASTS TO A STOP AND I AM ABLE TO RE-START IT, IT STARTS WITHOUT A PROBLEM.  MY VOLVO DEALERSHIP SAYS THEY SEE NO EVIDENCE OF PROBLEM ON THE CAR'S COMPUTER SYSTEM, AND THE CAR DID NOT DIE WHEN THEY TEST DROVE IT, THEREFORE THEY SAY THEY CANNOT DIAGNOSE THE PROBLEM - AND THAT WITHOUT A DIAGNOSIS, THEY CANNOT REPAIR IT.  THEY ALSO CLAIM THAT VOLVO'S DATABASE HAS NO RELATED VEHICLE OR PARTS RECALL ON MY PARTICULAR VIN/VEHICLE.    HOWEVER, WITH ABSOLUTELY NO WARNING OF WHEN THE ENGINE FAILURE WILL OCCUR, AND WITH NO CONTROL OVER STEERING OR BRAKING, THIS IS A VERY DANGEROUS SITUATION THAT VOLVO SO FAR CANNOT ADDRESS UNLESS THE ENGINE FAILURE HAPPENS RIGHT IN FRONT OF THEM.  WITH NO WAY OF CONTROLLING WHEN THE CAR WILL DIE, THIS IS OBVIOUSLY NOT A SATISFACTORY RESOLUTION FOR THE SAFETY OF MYSELF OR FOR OTHER DRIVERS.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10352672,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/27/2010","dateComplaintFiled":"08/30/2010","vin":"YV1RS59V042","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING APPROXIMATELY 60 MPH THE VEHICLE STALLED AND THE CHECK ENGINE LIGHT ILLUMINATED ON THE DASHBOARD.  THE VEHICLE WAS PULLED OVER AND SHUT OFF.  UPON RESTART IT OPERATED AS NORMAL BUT THE CHECK ENGINE LIGHT CONTINUED TO ILLUMINATE ON THE DASHBOARD.  THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THERE WAS A FAILURE WITHIN THE FUEL PRESSURE SENSOR.  OVER THE PAST 2 YEARS THE VEHICLE WAS EXPERIENCING AN INTERMITTENT FAILURE IN WHICH IT WOULD MOMENTARILY FAIL TO RESPOND TO PRESSURE BEING APPLIED TO THE ACCELERATOR PEDAL.  THE MANUFACTURER WAS NOTIFIED AND HE WAS INFORMED THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER  07V226000, ENGINE AND ENGINE COOLING.  THE VEHICLE WAS NOT REPAIRED.  THE FAILURE AND CURRENT MILEAGES WERE 77,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10349944,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/16/2010","dateComplaintFiled":"08/17/2010","vin":"YV1RS61T142","components":"ENGINE AND ENGINE COOLING","summary":"1. REFERENCE - ODI ID NUMBER : 10348993  THE CAR STALLED AGAIN ON THE HIGHWAY AND I WAS ABLE TO MANAGE TO PULL OVER SAFELY.   2. THIS TIME IT WAS DIAGNOSED WITH THE FUEL PRESSURE SENSOR. THE DEALER AND VOLVO CUSTOMER CARE REP STATED THAT THE RECALL IS NOT APPLICABLE TO THE CAR BECAUSE THE LAST 6-DIGIT VIN [XXX] IS OUT OF RANGE OF 335112 TO 372809. THE VOLVO CUSTOMER CARE REP ALSO STATED THERE IS NO GUARANTEE IF THE PROBLEM WILL NOT HAPPEN AGAIN WITHIN THE 12 MONTH PART WARRANTY AFTER IT'S FIXED. I FEEL VERY UNSAFE DRIVING THE CAR NOW, NOT KNOWING WHEN THE PROBLEM OCCURS AGAIN AND COULD CAUSE A FATAL CRASH.  3. DEALER REPLACES FUEL PRESSURE REGULATOR. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10348993,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/09/2010","dateComplaintFiled":"08/12/2010","vin":"YV1RS61T142","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE","summary":"1. VEHICLE STALLED 2 TIMES, LAST YEAR AND ON 08/09/2010 WHILE DRIVING ON HIGHWAY. I WAS ABLE TO RESTART BOTH TIME. THE SECOND TIME I WAS ABLE TO RESTART AFTER 5 MINUTES AND DRIVE TO THE NEARBY THE VOLVO STORE DEALERSHIP.  2. THE DEALERSHIP DIAGNOSED THE PROBLEM AND DETERMINED THE BATTERY WAS THE ISSUE. HOWEVER I SEE 2 RECALL CAMPAIGN ID NUMBERS: 09V483000 AND 07V226000 WHICH MAY BE THE ROOT CAUSE OF THE PROBLEM. I TALKED TO THE SERVICE MANAGER AT THE VOLVO STORE DEALERSHIP (1051 W. WEBSTER AVE, WINTER PARK, FL 32789 - 407-628-0550) BUT THE DEALERSHIP WON'T LOOK AT IT BECAUSE THEY SAID MY CAR IS NOT SHOWN UP FOR RECALL IN THEIR VOLVO DATABASE.   3. REPLACE THE BATTERY. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10348425,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"08/10/2010","dateComplaintFiled":"08/10/2010","vin":"YV1RS59V642","components":"POWER TRAIN,AIR BAGS","summary":"WHEN PULLING INTO A PARKING SPACE AT MY DAUGHTER'S SCHOOL, VEHICLE SUDDENLY ACCELERATED OVER THE SIDEWALK AND STRUCK THE BUILDING.  TRANSMISSION POPPED IN REVERSE AND VEHICLE ACCELERATED BACKWARDS.  EVEN WITH THE BRAKE PEDAL ALL THE WAY TO THE FLOOR, VEHICLE WOULD NOT STOP.  I FORCED THE TRANSMISSION INTO PARK AND TURNED OFF THE VEHICLE TO GET IT TO STOP AFTER GOING IN REVERSE FOR APPROXIMATELY 50 FEET.  THERE WAS SIGNIFICANT DAMAGE TO THE CAR AND BUILDING (PICTURES AVAILABLE).  NONE OF THE AIRBAGS DEPLOYED. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10345958,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/15/2009","dateComplaintFiled":"07/28/2010","vin":"YV1RH52Y742","components":"ELECTRICAL SYSTEM,EXTERIOR LIGHTING","summary":"I OWN A 2004 VOLVO S60R THAT HAS TURN SIGNAL ISSUES.  THERE WAS NO EVENT LEADING UP TO THE FAILURE.  SIMPLY ONE DAY IT NO LONGER WORKED 100% OF THE TIME.  WHEN USING THE TURN INDICATOR STOCK TO SIGNAL A LEFT TURN IT WILL NOT DO SO IF I FULLY DEPRESS IT INTO THE LOCK POSITION.  IF I HOLD IT ONLY PART OF THE WAY BEFORE IT LOCKS INTO THE POSITION IT  SOMETIMES WORKS.  IF I DO PUT IT INTO THE FULLY LOCKED POSITION AND TURN THE STEERING WHEEL SOMETIMES IT MAY WORK AND SOMETIMES IT MAY NOT.  THIS ONLY EFFECTS THE LEFT TURN SIGNAL AND NOT THE RIGHT.  I SAW THE FOLLOWING ARTICLE (HTTP://WWW.BUSINESSWEEK.COM/NEWS/2010-07-26/VOLVO-SUVS-EXAMINED-FOR-ELECTRONICS-FLAWS-U-S-SAYS.HTML) ABOUT THE 2004 - 2005 XC90 EXHIBITING THE SAME BEHAVIOR WITH THE TURN SIGNAL STALK INTERMITTENTLY WORKING.  OBVIOUSLY THE CONSEQUENCES WOULD BE DISASTROUS IF I CANNOT SIGNAL MY INTENTIONS ON LANE CHANGING AND OTHERS WOULD THEN COLLIDE INTO ME CAUSING INJURY AND POSSIBLY DEATH TO EITHER ONE OR ALL PARTIES INVOLVED.  NO PARTS HAVE BEEN REPLACED AND THE DEFECTIVE PART IS STILL INSTALLED ON MY VEHICLE. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10343456,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/05/2010","dateComplaintFiled":"07/15/2010","vin":"YV1RS61T542","components":"ELECTRICAL SYSTEM,LATCHES/LOCKS/LINKAGES","summary":"2004 VOLVO S60 IGNITION KEY FAILURE: KEY REFUSED TO TURN CAR WILL NOT START. CAR WILL NOT GO IN TO NEUTRAL. CAR MUST BE ABANDONED OCCUPANTS MUST SEEK TRANSPORTATION.    FIRST OCCURRENCE  APRIL 17TH 2008. SECOND OCCURRENCE JULY 5TH. 2010.  CAR TOWED TO DEALER AND IGNITION LOCK REPLACED BOTH TIMES.  TOTAL COST  $1662.48. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10342321,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/02/2010","dateComplaintFiled":"07/09/2010","vin":"YV1RS59V342","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER","summary":"THE ENGINE LIGHT CAME ON IN MY 2004 VOLVO S60. THE CAR WOULD LOOSE ACCELERATION. TOOK IT TO OUR MECHANIC AND HE SAID IT WAS THE FUEL PRESSURE SENSOR AND THAT IT HAD BEEN RECALLED BY VOLVO- RECALL # 07V226000. TOOK IT TO THE DEALER AND THEY SAID THAT THE VIN # OF MY CAR WAS NOT INCLUDED IN THE RECALL. IT WAS THE SAME PART THAT WAS RECALLED ON OTHER 2004 S60S. THE COST WAS $450 TO REPAIR. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10341236,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/10/2009","dateComplaintFiled":"07/02/2010","vin":"YV1RS61D142","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60 . WHILE DRIVING 5 MPH, MAKING A RIGHT, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE OCCURRED 5 TIMES. THE DEALER WAS CONTACTED AND STATED THAT THE ENGINE WAS OUT OF CODE WITH HIGH MILEAGE. THE VIN WAS NOT A PART OF NHTSA RECALL CAMPAIGN ID NUMBER, 07V226000, ENGINE AND ENGINE COOLING. THE DIAGNOSTIC TEST CONFIRMED THAT THE ECM 2600 FAILED AND IT WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS  67000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10334559,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/29/2010","dateComplaintFiled":"06/04/2010","vin":"YV1RS61T642","components":"ENGINE AND ENGINE COOLING","summary":"EXPANSION OF NHTSA CAMPAIGN ID NUMBER 07V226000 ( VOLVO RECALL NO. R181)FOR FUEL PRESSURE SENSOR.  HAVE SAME MAKE, MODEL  AND YEAR.  MANUFACTURE INDICATES MY VIN NOT COVERED.  DEALER REPLACED FUEL PRESSURE SENSOR.  ERROR CODE ON CAR P0194.  DESCRIPTION MATCHES RECALL.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10330306,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/13/2010","dateComplaintFiled":"05/13/2010","vin":"YV1RS59V442","components":"FUEL SYSTEM, GASOLINE","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. WHILE TURNING ON THE VEHICLE, THE CONTACT NOTICED THAT THE CHECK ENGINE LIGHT HAD ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE SENSOR WAS THE CAUSE FOR THE LIGHT. THE DEALER RESET THE SENSOR. THE LIGHT ILLUMINATED AGAIN SO THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT FUEL SENSOR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AT THE TIME OF THE COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 93,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10328850,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/09/2010","dateComplaintFiled":"05/04/2010","vin":"YV1RS59V442","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT SEVERAL TIMES WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE WOULD SUDDENLY SHUT DOWN ACCOMPANIED BY THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC WHO INFORMED THE CONTACT THAT THE FUEL PRESSURE SENSOR MALFUNCTIONED AND CAUSED THE FAILURE TO OCCUR; HOWEVER, THE DEALER STATED THAT RECALL 07V226000 (ENGINE AND ENGINE COOLING) DID NOT INCLUDE THE CONTACTS VIN. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. THE CURRENT MILEAGE WAS APPROXIMATELY 112,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10328633,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"05/02/2010","dateComplaintFiled":"05/03/2010","vin":"YV1RS64A542","components":"EQUIPMENT","summary":"I HAVE 2004 VOLVO S60VOLVO . I WAS TRYING TO RAISE MY VEHICLE ON THE OEM JACK CAME WITH MY CAR TO CHANGE THE WHEEL. AFTER FEW SECOND I REMOVED MY TIRE , THE JACK COLLAPSED - AND MY CAR CAME CRASHING DOWN. I WAS LUCKY AS I HAD STUCK MY HEAD INTO THE WHEEL WELL MOMENTS BEFORE TO CHECK MY BRAKE PADS AND ROTORS, AND HAD MY FINGERS AROUND THE SUSPENSION LINKAGES. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10327845,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/03/2009","dateComplaintFiled":"04/28/2010","vin":"YV1RS59V642","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE HESITATED, DECREASED IN ENGINE PERFORMANCE, THE CHECK ENGINE LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT TURNED OFF THE IGNITION RESTARTED IT TO MOVE TO THE SIDE OF THE ROAD. THE FAILURE OCCURRED ON FOUR OTHER OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 90,000. THE FAILURE MILEAGE WAS APPROXIMATELY 87,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10327868,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/14/2010","dateComplaintFiled":"04/28/2010","vin":"YV1RH59H042","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60. THE CONTACT STATED THAT WHILE DRIVING IN WET CONDITIONS AT APPROXIMATELY 50 MPH, WITH ALL WHEEL DRIVE ENGAGED, THE EXHAUST SYSTEM WOULD EXPAND, CAUSING IT TO RUB AGAINST THE DRIVETRAIN. THE FAILURE CAUSED A LOUD NOISE UNDERNEATH THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO AN AUTHORIZED DEALERSHIP TO HAVE AN EXHAUST BRACKET APPLIED. THE CONTACT FELT THAT THE MANUFACTURER SHOULD HAVE BEEN RESPONSIBLE FOR THE REPAIR EXPENSES AS IT WAS UNSAFE TO HAVE MOVING OBJECTS RUBBING AGAINST EACH OTHER. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10323896,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/29/2009","dateComplaintFiled":"04/05/2010","vin":"YV1RH52Y742","components":"ENGINE AND ENGINE COOLING","summary":"IN JULY OF 2009 DURING THE WASHINGTON STATE HEAT WAVE, WHERE TEMPERATURES REACHED 104, MY 2004 VOLVO S60R EXPERIENCED A ENGINE SHUTDOWN ON THE FREEWAY THAT WAS DESCRIBED IN A RECALL (07V226000) FOR MY MODEL AND YEAR.  MY VEHICLES VIN WAS NOT PART OF THE VEHICLES THAT WERE PART OF THE RECALL HOWEVER I THINK YOU SHOULD EXPAND THE RANGE SINCE MY VEHICLE ALSO HAD THE FUEL PRESSURE SENSOR REPLACED TO SOLVE THE ISSUE.  I STILL HAVE THE PART IF YOU WANT TO EXAMINE IT.  I HAVE READ THE CONSEQUENCES PART OF THE RECALL (07V226000) AND THAT IS EXACTLY WHAT I EXPERIENCED.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10323302,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/01/2010","dateComplaintFiled":"04/01/2010","vin":"YV1RS61T842","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER","summary":"FUEL PRESSURE SENSOR FUNCTIONING OUTSIDE OF ITS NORMAL PARAMETERS  ECM CODE 2600. THERE IS RECALL ON THE PROBLEM BUT DEALER WILL NOT REPLACE THE SENSOR FREE OF CHARGE. RECALL #07V226000","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10310558,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/15/2010","dateComplaintFiled":"02/15/2010","vin":"YV1RH59H542","components":"FUEL SYSTEM, OTHER","summary":"VOLVO S60, 2004 RECALL LETTER DATED JANUARY 15, 2010. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10310587,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/10/2009","dateComplaintFiled":"02/15/2010","vin":"YV1RS64A442","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE","summary":"CERTIFIED PREVIOUSLY OWNED VEHICLE STALLED DUE TO BUTTERFLY VALVE WITHIN THROTTLE BODY NOT OPENING FAST ENOUGH WHEN GOING AROUND A CORNER AND TOO MUCH LOAD ON THE ENGINE. EXAMPLE: EXITED FREEWAY AND WAS TURNING LEFT WHILE BRAKING DUE TO UPCOMING RED LIGHT. THE ENGINE STALLED IN THE MIDDLE OF AN INTERSECTION WHILE THE VEHICLE WAS IN MOTION AT APPROXIMATELY 10 MPH. LOST STEERING AND BRAKING POWER. THE PROBLEM WAS FIRST NOTICED WHEN MAKING RIGHT TURNS AND HAVING TO SUDDENLY BRAKE FOR A PEDESTRIAN, BICYCLIST, OR OTHER TRAFFIC HAZARD AND THE ENGINE STALLING OR FLUTTERING AT MUCH LOWER SPEEDS. AS IT WORSENED OVER THE COURSE OF A WEEK IT WAS ULTIMATELY THE WORST WITH THE MID-INTERSECTION STALL. AT THIS POINT WE WERE AFRAID TO DRIVE THE VEHICLE FOR FEAR OF CRASHING. VEHICLE WAS PURCHASED FROM A DEALER AS CERTIFIED PRE-OWNED 68,735 MILES ON 05/02/2008 AND WAS TAKEN TO DEALER FOR STALLING AT 76,678 MILES ON 08/15/2009. DEALER REPORTED THIS AS A MAINTENANCE ISSUE NOT COVERED UNDER WARRANTY. REPAIRS FOR CLEANING THE THROTTLE BODY, RESETTING VALVE, AND INSTALLING NEW GASKETS WAS $402.93. VEHICLE ORIGINALLY PURCHASED IN SOUTHERN CALIFORNIA.  VEHICLE MOVED TO WASHINGTON IN FEBRUARY OF 2009. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10300051,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/16/2010","dateComplaintFiled":"01/17/2010","vin":"YV1RS61T642","components":"TIRES","summary":"DELAMINATION OF BRIDGESTONE BLIZZAK 15 INCH SNOW TIRE AT HIGHWAY SPEED, REAR LEFT TIRE.  NO INJURY OR DAMAGE BUT TIRE TREAD COMPLETELY SEPARATED FROM SIDEWALL AS ONE UNIT LIKE A DONUT.  1 YEAR OLD TIRES WITH LESS THAN 10,000 MILES. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Tire","productYear":"9999","productMake":"BRIDGESTONE","productModel":"BLIZZAK LM-25","size":"205/50R16","manufacturer":"Bridgestone Americas Tire Operations"}]},{"odiNumber":10295441,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/12/2009","dateComplaintFiled":"12/12/2009","vin":"YV1RS61T042","components":"ENGINE AND ENGINE COOLING","summary":"2004 S60 VOLVO STALLS WHILE DRIVING.  MOST RECENT OCCURRENCE STALLED WHILE TURNING, FORCING THE DRIVER TO DRIVE OFF THE ROAD TO AVOID TRAFFIC.  CAR HAS BEEN KNOWN TO STALL MULTIPLE TIMES DAY...DASHBOARD LIGHTS UP AT TIME OF OCCURRENCE AND ENGINE STOPS...POWER STEERING FAILS.  DIFFICULT TO CONTROL WHEN IT OCCURS BECAUSE OF THIS.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10292098,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/29/2008","dateComplaintFiled":"11/13/2009","vin":"YV1RS59V642","components":"ENGINE AND ENGINE COOLING","summary":"I-55 SOUTH SHORTLY BEFORE WEBER ROAD EXIT I WAS ON THE LEFT LANE TRAVELING 30 MPH, DECIDED TO CHANGE TO MIDDLE LANE, SIGNALED AND WHILE IN PROCESS OF LANE CHANGE, CAR STARTED TO GO OUT OF CONTROL. THEN STEERED TO THE LEFT, AND WAS HEADING TOWARDS CEMENT DIVIDER. TO AVOID THAT I STEERED RIGHT, AT THIS POINT CAR STARTED TO DO 360. COULD NOT CONTROL AND WAS MOVING TO FACE ONCOMING SEMI TRUCK FROM MIDDLE LANE. THE SEMI TRUCK SLAMMED INTO THE RIGHT SIDE (HEADLIGHT/TIRE) AREA OF MY CAR VOLVO S60 MODEL YEAR 2004 AND STOPPED THE CAR. BOTH AIRBAGS DEPLOYED - DRIVER AND PASSENGER AIRBAG. ONLY PERSON IN CAR WAS ME. PRIOR TO THE CRASH I EXPERIENCED AND FELT THAT THE FRONT CONTROL ARMS MAY NOT HAVE BEEN MANUFACTURED CORRECTLY AND AS A RESULT THE STUD AND NUT THAT SECURED SPINDLE MAY LOSE THEIR INITIAL AXIAL TENSION. UNDER CERTAIN AND PARTICULAR DRIVING CONDITIONS SUCH AS WEATHER CONDITIONS REMAINING SEVERE WITH HEAVY SNOW STORM, STEERING MIGHT BECOME LESS RESPONSIBLE AND THE DRIVER MAY EXPERIENCE DIFFICULTY IN CONTROLLING THE STEERING. THIS DRIVING CONDITION COULD HAVE BEEN THE APPROXIMATE CAUSE THAT LEAD TO SEPARATION BETWEEN CONTROL ARM AND THE SPINDLE WHICH HAD ULTIMATELY RESULTED IN A \"TOTAL CRASH\". I ALSO TRIED TO APPLY BRAKE. LOSS OF BRAKE FLUID, AS A RESULT OF FAILURE OF SEALED CARDONE MASTER CYLINDER WITH FLUID LEAKING FROM BRAKE HAD RESULTED IN CRASH. I ALSO OBSERVED CRUISE CONTROL SENSOR FAILURE, AFTER I TURNED IT \"ON\", THEN IT SHUTS OFF BY ITSELF, AGAIN I HAVE TO TURN ON.  WHILE DRIVING AT RATE 60 TO 65 MILES I OBSERVED A KIND OF NOISE AND VIBRATIONS UNDER HOOD. POSSIBLY THE FUEL PRESSURE SENSOR LOCATED OF THE FUEL RAIL MAY TRANSMIT INCORRECT SIGNAL TO THE ENGINE CONTROL MODULE. I OF THE OPINION THAT THIS MIGHT BE ONE OF THE CONTRIBUTING FACTOR RESPONSIBLE FOR STALLING OF ENGINE WITHOUT ANY WARNING AND HAS CAUSED A TOTAL CRASH ON THE FREEWAY. FAILURE OF THE FUEL PRESSURE SENSOR MIGHT HAVE CRACKED DUE TO TEMPERATURE CHANGES AND EXCESSIVE VIBRATIONS AND THAT CAUSED  CRASH. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10291584,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/09/2000","dateComplaintFiled":"11/09/2009","vin":"YV1RS64A742","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, OTHER,EXTERIOR LIGHTING","summary":"2004 VOLVO S60 REGULARLY SERVICED BY VOLVO.  BOUGHT NEW, WELL MAINTAINED, EXC COND, & OIL CHANGED EVER 3000 MILES.  ONLY 68K MILES PRESENTLY BUT MANY PROBLEMS SINCE BOUGHT NEW.  #1)  REPLACING BURNED OUT REAR/FRONT HEADLIGHT BULBS CONSTANTLY.   #2)  CHECK ENGINE LIGHT CAME ON BEFORE 40K MILES. WASN'T TOO CONCERNED AT FIRST BECAUSE ONLY ISSUE I SEEMED TO HAVE WAS HESITATION SOMEWHAT WHEN ACCELERATING AFTER BEING PARKED.  UNTIL ONE DAY VEH WOULDN'T ACCELERATE BEYOND A ROLL AFTER BEING STOPPED FOR RED LIGHT.  A FEW DAYS LATER DRIVING APPROX 50 MPH UPHILL CAR STOPPED ACCELERATING AND STALLED.  BOTH TIMES I WAS ABLE TO ROLL TO SIDE OF ROAD, RESTART & MAKE IT HOME.  SCARED ME ENOUGH THOUGH TO TAKE TO VOLVO NEXT DAY.  FUEL SENSOR GAUGE NEEDED TO BE REPLACED.  WHEN I CHECKED IF COVERED UNDER RECALL - FOUND MY CAR WASN'T BASED ON VIN, ANOTHER FAIRLY COSTLY REPAIR.   #3 - AC FAN WOULDN'T GO OFF ONE DAY - FAN RUNNING FULL BLAST & CONTROL SWITCH WOULDN'T REGULATE OR WORK.  FAN CONTINUED TO RUN EVEN WHEN I TURNED OFF IGNITION.  DEAD BATTERY NEXT MORNING NEEDED JUMP START.  AC FAN MODULAR BAD - MODULAR REPAIR DONE & THEN FAN SOMEHOW BURNED OUT DUE TO NEW MODULAR WHEN MECHANIC TESTING REPAIR - NOW FAN NEEDED TO BE REPLACED.  VERY COSTLY REPAIR ONCE AGAIN.  #3 -  CHECK ENGINE LIGHT CAME ON.   AFTER MONTHS TO SEVERAL MECHANICS, CHECKING OIL, ETC. TOLD LIGHT PROBABLY JUST FAULTY.  THEN CHECK OIL LIGHT BLINKS - CAR HAD LESS THAN 1/2 QT OIL & I HAD MAJOR ENGINE DAMAGE.   HAD COMPLETE ENGINE REBUILT & VERY EXPENSIVE.  ENGINE RUNNING GREAT.   NOW 2 MOS LATER & I HEAR A METAL TO METAL NOISE/SOUND WHEN MAKING TURNS - PREFERABLY RIGHT HAND - & COMING FROM RGHT FRONT SIDE OF CAR.  MECHANIC CAN'T SEE SAFETY ISSUES WHEN UP ON RACK.   HAS NO CLUE.  NOISE ANNOYING AND CONCERNING.  IT SOUNDS LIKE WHEEL IS GOING TO FALL OFF CAR.  I AM SURE IT WILL COST ANOTHER FORTUNE .  HOWEVER ONCE REPAIRED - TRADING IN.  I LOVED MY CAR...HOWEVER NO LONGER FEEL VEH IS SAFE OR DEPEN. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10290258,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/09/2009","dateComplaintFiled":"10/29/2009","vin":"YV1RH52Y842","components":"FUEL SYSTEM, GASOLINE","summary":"2004 VOLVO S60 R AWD WITH LESS THAN 65,000 MILES STARTED LEAKING FUEL THAT IS RUNNING DOWN THE PASSENGER SIDE OF THE GAS TANK AND THERE IS A VERY STRONG PUNGENT GAS ODOR EMITTED FROM THE PASSENGER SIDE OF THE REAR OF THE VEHICLE. TOOK THE CAR TO VOLVO OF GEORGETOWN AND LOCAL VOLVO MECHANIC WHO BOTH TOLD ME THAT THE VEHICLE NEEDED A NEW FUEL PUMP BUT I WAS NOT COVERED UNDER THE S60 FUEL PUMP RECALL A FEW YEARS PRIOR. BIG SAFETY HAZARD AND CONCERN! *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10289077,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/12/2009","dateComplaintFiled":"10/20/2009","vin":"YV1RS64A642","components":"ENGINE AND ENGINE COOLING","summary":"TL* THE CONTACT OWNS A 2004 VOLVO S60. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT CONTROL PANEL.  HE RECEIVED ENGINE ERROR CODES THAT WERE REFERENCED IN  RECALL ID NUMBER: 07V226000. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALERSHIP. THE CURRENT AND FAILURE MILEAGES WERE 62000.         UPDATED 11/3/09 *CN  THE CONSUMER STATED THE FUEL RAIL SENSOR IS BAD AND HIS VEHICLE SHOULD HAVE BEEN INCLUDED IN THE RECALL. UPDATED 11/05/09/.*JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10279497,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/13/2008","dateComplaintFiled":"08/05/2009","vin":"YV1RS61T742","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING 50 MPH, THE VEHICLE SHUT OFF WITHOUT WARNING.  THE CONTACT WAS ABLE TO SAFELY MANEUVER THE VEHICLE TO THE SHOULDER OF THE ROAD.  THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING) IN OCTOBER OF 2008.  THE FAILURE HAS RECENTLY RECURRED.  THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DETERMINE THE CAUSE OF THE RECURRENCE.  THE VEHICLE IS CURRENTLY AT THE DEALER AND THE MECHANICS ARE ATTEMPTING TO DUPLICATE THE FAILURE.  THE MANUFACTURER STATED THAT NO COMPENSATION WOULD BE PROVIDED BECAUSE THE VEHICLE WAS PREVIOUSLY REPAIRED ACCORDING TO A RECALL.  THE CONTACT FEELS THAT THE PART THAT WAS REPLACED DURING THE RECALL REPAIR IS FAILING.  THE VEHICLE HAS NOT BEEN REPAIRED.  THE FAILURE MILEAGE WAS 52,000 AND CURRENT MILEAGE WAS 80,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10276538,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/02/2009","dateComplaintFiled":"07/13/2009","vin":"YV1RS59V842","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING APPROXIMATELY 25 MPH, THERE WAS NO RESPONSE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED.  SUDDENLY,THE ENGINE STALLED.  THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL.  ROADSIDE ASSISTANCE WAS CALLED TO THE SCENE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR INSPECTION.  THE TECHNICIAN STARTED THE ENGINE, BUT WAS UNABLE TO DUPLICATE THE FAILURES.  THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON A SEPARATE OCCASION FOR IDENTICAL FAILURES AND THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE SENSOR FAILED.  THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING), ALTHOUGH THE FAILURES WERE IDENTICAL.  THE VEHICLE WAS REPAIRED AT THE CONTACT'S EXPENSE.  THE FAILURE AND CURRENT MILEAGES WERE 77,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10274825,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/11/2009","dateComplaintFiled":"06/24/2009","vin":"YV1RS61T342","components":"ENGINE AND ENGINE COOLING","summary":"2004 VOLVO S60, STALLS /CUTS-OFF WHILE DRIVING FOR NO REASON. DEALER UNABLE TO DIAGNOSIS PROBLEM. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10269592,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/10/2009","dateComplaintFiled":"05/21/2009","vin":"YV1RS59VX42","components":"ENGINE AND ENGINE COOLING","summary":"DISPLAYS \"CHECK ENGINE\" MOST OF THE TIME AND DOWNLOADS TO A FUEL PRESSURE SENSOR. AUTO HESITATES PERIODICALLY AND HAS ON 4 SEPARATE OCCASIONS STALLED COMPLETELY.  07V226000 HAS A RECALL FOR THIS EXACT PROBLEM BUT VOLVO SAYS MY VIN NOT AFFECTED. SEEMS FROM SEEING OTHER COMPLAINTS WITH SAME PROBLEM THAT VOLVO UNDERESTIMATED THEIR PROBLEM. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10265737,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/17/2007","dateComplaintFiled":"04/17/2009","vin":"YV1RS64A442","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING 10 MPH, THE VEHICLE BEGAN TO DECELERATE AND THEN STALLED.  THE ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT CONTROL PANEL.  FIVE MINUTES AFTER THE FAILURE OCCURRED, THE VEHICLE RESTARTED ITSELF.  TWO DAYS LATER, THE VEHICLE WOULD NOT START.  THE MANUFACTURER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING); THEREFORE, THEY WOULD NOT ASSUME ANY RESPONSIBILITY FOR THE REPAIRS.  THE VEHICLE HAS NOT BEEN REPAIRED.  THE FAILURE AND CURRENT MILEAGES WERE 64,450.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10262478,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/03/2009","dateComplaintFiled":"03/19/2009","vin":"YV1RS59V042","components":"FUEL SYSTEM, OTHER","summary":"2004 VOLVO S60 FUEL PRESSURE SENSOR.  VOLVO ISSUED A RECALL FOR THIS FOR 2003-2004 MODELS.  MY CAR HAD THIS PROBLEM AND ITS SYMPTOMS (CAR STALLING).  VOLVO DEALERSHIP SAID MY CAR DID NOT FALL INTO RECALL DUE TO VIN # BREAK.  VOLVO CORPORATION NEVER BOTHERED TO RETURN MY CALLS.  I FEEL THAT I SHOULD BE REIMBURSED FOR THIS REPAIR AS IT CLEARLY MEETS THE RECALL DESCRIPTION. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10255132,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/08/2009","dateComplaintFiled":"01/15/2009","vin":"YV1RH59H242","components":"PARKING BRAKE","summary":"PARKING BRAKE PAD DELAMINATED FROM SHOE: DISLODGED AFTER DRIVING OVER A BUMP IN THE ROAD AND BECAME WEDGED INTO REAR SPINDLE CAUSING WHEEL TO LOCK UP AND RESULTED IN MAJOR DAMAGE TO BRAKE AND WHEEL COMPONENTS.  1 OCCURRENCE, REQUIRED REPLACEMENT OF LEFT REAR ROTOR, BACKING PLATE, SPINDLE, PARKING BRAKE SHOES (BOTH SIDES) AND PARKING BRAKE CABLE. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10255669,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/01/1901","dateComplaintFiled":"01/15/2009","vin":"","components":"ENGINE AND ENGINE COOLING","summary":"2004 VOLVO S60 MAY HAVE A PRESSURE SENSOR PROBLEM.   CONSUMER STATES THAT THERE IS NO VOLVO DEALER IN HER AREA AND NEEDS HELP WITH FINDING ONE.   *NJ","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10253930,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/03/2009","dateComplaintFiled":"01/06/2009","vin":"YV1RS59V342","components":"ENGINE AND ENGINE COOLING","summary":"2004 VOLVO S60    ENGINE STALLS WITHOUT WARNING, ERROR CODE OF \"FUEL PRESSURE SENSOR\" INDICATED BY CHECK ENGINE LIGHT/ONBOARD DIAGNOSTICS.    EXACT SAME PROBLEM IS ALREADY PART OF NHTSA RECALL BULLETIN  REFERENCE NUMBER(S): 07V226000     HOWEVER, NOT ALL 2004 S60 VIN'S ARE BEING COVERED.    THIS IS AN EXTREMELY DANGEROUS SITUATION!  SUDDEN LOSS OF ENGINE POWER/STALLING AT HIGHWAY SPEEDS COULD EASILY RESULT IN A FATAL ACCIDENT FOR PASSENGERS AND OTHER MOTORISTS.    VOLVO NEEDS TO EXPAND THE RECALL/BULLETIN TO INCLUDE ALL 2004 VOLVO S60 MODELS! *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10253603,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"11/20/2008","dateComplaintFiled":"01/02/2009","vin":"","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING LESS THAN 50 MPH AND SLOWING DOWN TO MAKE A TURN, THE VEHICLE STALLED.  THIS BECAME A PATTERN WHEN ATTEMPTING TO MAKE LEFT AND RIGHT TURNS.  THE DEALER STATED THAT THERE WAS A RECALL FOR THE FAILURE; HOWEVER, HIS VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING).  NO REPAIRS HAVE BEEN MADE TO DATE.  THE VIN WAS UNKNOWN.  THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 92,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10246979,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/26/2007","dateComplaintFiled":"10/28/2008","vin":"YV1RS64A742","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  THE CONTACT STATED THAT THE VEHICLE WOULD SPORADICALLY STALL WITHOUT WARNING.  SPEED WAS NOT A FACTOR DURING THE FAILURES.  A MECHANIC INSPECTED THE VEHICLE, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED.  THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 07V226000 (ENGINE AND ENGINE COOLING).  AS OF OCTOBER 28, 2008, THE VEHICLE HAS NOT BEEN REPAIRED.  THE FAILURE MILEAGE WAS 55,000 AND CURRENT MILEAGE WAS 58,888.      UPDATED 12-02-08 *BF  UPDATED 12/02/08. *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10246583,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/11/2008","dateComplaintFiled":"10/24/2008","vin":"","components":"POWER TRAIN","summary":"ANGLE GEAR FAILURE IN VOLVO S60R AWD.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10244189,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/03/2008","dateComplaintFiled":"10/02/2008","vin":"YV1RS61T842","components":"ENGINE AND ENGINE COOLING,FUEL SYSTEM, GASOLINE","summary":"TL*THE CONTACT'S SPOUSE OWNS A 2004 VOLVO S60.  ON APPROXIMATELY TWENTY OCCASIONS, THE VEHICLE WOULD COMPLETELY SHUT OFF AND NEED TO BE RESTARTED INTERMITTENTLY.  THE FAILURE OCCURRED WHILE BRAKING OR TURNING THE VEHICLE. THE DEALER WAS ABLE TO DUPLICATE THE FAILURE, BUT COULD NOT GET AN ERROR CODE FROM THE DIAGNOSTIC MACHINE. RECALL NUMBER 07V226000 IS REGARDING THE SAME ISSUE; HOWEVER, THE VIN IS NOT INCLUDED. THE CURRENT MILEAGE WAS 92,000 AND FAILURE MILEAGE WAS 91,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10244245,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/20/2008","dateComplaintFiled":"10/02/2008","vin":"","components":"ELECTRICAL SYSTEM","summary":"DRIVING ALONG THE HIGHWAY AT BOUT 70 MPH, THE CAR SUDDENLY HESITATES AND LOSES POWER (THE RPM READER, AND SPEEDOMETER FALL TO 0). THE CAR THEN REGAINS POWER AND THEN IT JERKS AND HESITATES, ONCE AGAIN LOSING POWER. THIS TIME THE POWER STAYS OUT.     HAVEN'T HAD THE PROBLEM FIXED YET  THE INITIAL ACCELERATION OF THE CAR IS EXTREMELY SLOW AND IT REQUIRES A HARD PRESS ON THE GAS TO GET THE CAR IN MOTION. THE POWER DOESN'T WORK FOR THE FOLLOWING FUNCTIONS:    POWER LOCK (INCLUDING THE REMOTE)   ALL STEERING WHEEL FUNCTIONS (RADIO AND CRUISE  CONTROL)  HEADLIGHTS  TURN SIGNALS  WINDSHIELD WIPERS  SUN ROOF  SIDE AND REAR VIEW MIRRORS  AIR CONDITIONING CONTROLS  ALL GAUGES IN THE DASHBOARD.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10243524,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/23/2008","dateComplaintFiled":"09/26/2008","vin":"","components":"ELECTRICAL SYSTEM,EXTERIOR LIGHTING","summary":"BULBS CONTINUOUSLY BURNS OUT CAUSING ERRORS THAT CANNOT BE READILY FIX BY THE OWNER.  BULBS SUCH AS FOR HEADLIGHTS, TURN SIGNALS AND REAR LIGHTS BURN OUT CONSTANTLY.  WE ARE AVERAGING A BULB REPLACEMENT EVERY 2 MONTHS. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10241603,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/08/2008","dateComplaintFiled":"09/09/2008","vin":"YV1RS61T142","components":"FUEL SYSTEM, GASOLINE","summary":"I WAS DRIVING ABOUT 65 MILES AN HOUR IN THE LEFT HAND LANE OF AN INTERSTATE YESTERDAY WHEN MY CAR STALLED AND DIED.  THE VOLVO DEALERSHIP STATES IT IS NOT SUBJECT TO RECALL, YET THE INCIDENT IS IDENTICAL TO PROBLEM DESCRIBED IN NHTSA CAMPAIGN NUMBER 07V226000.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10240972,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/03/2008","dateComplaintFiled":"09/04/2008","vin":"YV1RS61TX32","components":"EXTERIOR LIGHTING","summary":"ABOUT EVERY 2-3 MONTH WHEN I GO TO START MY VOLVO S60 THE FRONT LEFT LIGHT BLOWS OUT.  I HAVE HAD MY CAR FOR A LITTLE OVER A YEAR AND HAVE HAD TO REPLACE THE HEADLAMPS 5 TIMES.  THE FIRST TIME I CHANGED THE LIGHTS I DID NOT WEAR GLOVES SO IT COULD HAVE POSSIBLE BEEN MY FAULT.   EVERYTIME AFTER I HAVE WORN GLOVES TO CHANGE THE LIGHTS AND STILL HAVE THE SAME PROBLEM. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10240176,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"08/26/2008","dateComplaintFiled":"08/29/2008","vin":"YV1RH59HX42","components":"AIR BAGS","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING BETWEEN 25-30 MPH, THE CONTACT STRUCK A DEER AND THE VEHICLE FLIPPED OVER.  NONE OF THE AIR BAGS DEPLOYED.  A POLICE REPORT WAS FILED.  THE VEHICLE WAS DESTROYED.  THE CONTACT SUSTAINED BACK AND NECK INJURIES.  THE CONTACT HAS PICTURES.  THE CURRENT AND FAILURE MILEAGES WERE 41,000.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10238544,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/14/2008","dateComplaintFiled":"08/17/2008","vin":"YV1RH52Y342","components":"TIRES","summary":"FAILURE OCCURRED WITH PIRELLI P-ZERO ROSSO 235/40-18 TIRES.  FAILURE OCCURRED IN CONSTRUCTION ZONE WITH VEHICLE TRAVELING 5 MI OVER POSTED SPEED LIMIT.  ROAD WAS BEING REFINISHED.  LEFT FRONT TIRE IMPACTED WITH RAISED MANHOLE.  IMPACT CAUSED BULGE IN TIRE SIDEWALL.  SIMILAR EVENT ALSO HAPPENED IN APRIL 2006 WHEN DRIVING SAME CAR IN ANOTHER CONSTRUCTION ZONE.  DROVE OVER STEEL PLATE IN ROAD AT SLIGHTLY ABOVE POSTED SPEED LIMIT.  LEFT FRONT TIRE IMPACTED PLATE AND BULGE APPEARED.  IN BOTH INCIDENTS, TWO NEW TIRES HAD TO BE PURCHASED (4 TOTAL).  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Tire","productYear":"9999","productMake":"PIRELLI","productModel":"UNKNOWN","size":null,"manufacturer":"Pirelli Tire, LLC"}]},{"odiNumber":10236160,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/21/2007","dateComplaintFiled":"07/28/2008","vin":"YV1RS59VX42","components":"ENGINE AND ENGINE COOLING,VISIBILITY,AIR BAGS,SERVICE BRAKES, ELECTRIC","summary":"2004 VOLVO S60 2.5 TURBO:  NO WARNING TO THE EVENTS.  ON NUMEROUS OCCASIONS, THE CAR FEELS AS IF IT HAS HIT A LARGE OBJECT, TEMPORARILY LURCHES AND APPEARS TO MOMENTARILY STALL CREATING A TEMPORARY LOSS OF VEHICLE CONTROL.  THIS IS FOLLOWED BY AN IMMEDIATE LOSS OF ALL INSTRUMENT GAUGES,  AIR CONDITIONER, WINDOW CONTROLS AND DOOR LOCKS.  THE FAN DID CONTINUE TO WORK. THE ABS WARNING LIGHT ALSO INDICATED AS WELL AS A WARNING THAT NO BRAKES FUNCTION EXISTED.  THE SRS SERVICE AIR BAG URGENT INDICATION IS ILLUMINATED.  ON TURNING THE CAR OFF AND RESTARTING, THE FUNCTIONS OF THE CAR RETURN WITH EXCEPTION THAT THE SRS SERVICE AIR BAG URGENT INDICATION REMAINS.  THIS PROBLEM CAN TAKE MONTHS TO REPEAT OR ONLY A MATTER OF MINUTES.  IT SEEMS TO BE MORE PREVALENT IN HOT WEATHER.  THE VEHICLE WAS TAKEN TO THE SERVICE SHOP AT THE VOLVO DEALER AND THEY COULD ONLY CLEAR ALARMS AS THEY SAID THE EVENT CREATED TOO MANY ALARMS/FAULT CODES TO TROUBLESHOOT.  THEY DOWNLOADED NEW SOFTWARE REVISIONS TO EACH CONTROL MODULE IN THE CAR.  AFTER A PERIOD OF APPROXIMATELY A MONTH, THE EVENTS BEGAN OCCURRING AGAIN.  THE VEHICLE HAS BEEN TAKEN TO NON OEM MECHANICS AS WELL AND THEY ARE NOT ABLE TO TROUBLESHOOT THE FAULT.  THE VEHICLE IS SCHEDULED TO BE TAKEN TO THE DEALERS SERVICE SHOP AGAIN.  SEARCHING THE INTERNET CHAT ROOMS AND BLOGS, AS WELL AS THIS SITE, THERE APPEARS TO BE NUMEROUS OTHER VEHICLES WITH THIS SAME SAFETY FAULT THAT STALLS VEHICLES IN TRAFFIC AND CREATES VERY SUDDEN AND SEVERE LURCHES IN POWER ULTIMATELY LEADING TO A MOMENTARY STALL OUT WITH LOSS OF ALL INSTRUMENT INDICATIONS TO INCLUDE SPEED, RPM, TURN INDICATOR, ETC.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10235108,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/01/2007","dateComplaintFiled":"07/21/2008","vin":"YV1RS59V942","components":"TIRES,EQUIPMENT","summary":"LATE LAST SUMMER, UPON STARTING UP MY CAR, I NOTICED A HISSING NOISE COMING FROM THE CENTER PANEL ON THE DASHBOARD.  DIDN'T REALLY THINK ANYTHING OF IT UNTIL I TRIED TO TURN ON THE AIR CONDITIONER AND THE CAR MADE THE SAME HISSING NOISE.  NOISE LASTS ONLY 5-10 SECONDS UPON STARTUP OF THE CAR OR THE AC, BUT NOW THE AC ONLY BLOWS HOT AIR.  TOOK CAR TO VOLVO DEALERSHIP HERE IN SOUTHERN CALIFORNIA WHERE I PURCHASED THE CAR AND THEY SAID THAT THEY WERE GOING TO HAVE TO RIP OPEN THE ENTIRE FRONT PANEL TO INVESTIGATE THE PROBLEM.  AS I HAVE BEEN TOLD TWICE PREVIOUSLY BY THIS DEALERSHIP THAT I NEED SERVICE THAT I DID NOT REALLY NEED (THIS WAS NOW THE THIRD TIME), I CHOSE TO HOLD OFF ON LETTING THEM PERFORM SUCH A TASK.  INSTEAD, I TOOK THE CAR TO ANOTHER MECHANIC AND DESCRIBED THE PROBLEM TO HIM.  HE LET ME KNOW THAT WHEN THERE WAS NO FREON LEFT IN THE AC UNIT.  THEY REPLACED IT AND WITHIN ONE DAY, IT HAD COMPLETELY LEAKED.  THEY THEN PERFORMED AN INSPECTION ON THE AC AND EITHER THE COMPRESSOR OR THE HOSES HAS A MAJOR LEAK IN IT.  I HAVE NO ACCIDENTS AND THE CAR HAS LESS THAN 60,000 MILES ON IT CURRENTLY.  THE PROBLEM WAS FIRST DETECTED AT LESS THAN 45,000 MILES ON IT.  ESTIMATE ON REPAIR WAS $1500+.  AT 22,500 MILE CHECKUP, VOLVO REPLACED RADIATOR ON CAR.  MECHANIC SAID THAT IT WAS POSSIBLE THAT VOLVO DEALERSHIP MAY HAVE DAMAGED THE AC UNIT AT THAT TIME SINCE THEY ARE IN CLOSE PROXIMITY.  IN ADDITION, AS I NOTICED ON ANOTHER PERSON'S COMPLAINT FORM, I ALSO HAVE THE RUBBING OF THE FRONT TIRES WHEN TURNING.  QUITE ANNOYING AND I DO MY BEST TO AVOID THE FRICTION AT ALL COSTS.  DOESN'T OCCUR ON NORMAL TURNS, JUST WHEN MANEUVERING FOR PARKING SPACES OR GETTING OUT OF MY PARKING GARAGE. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10232678,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/24/2008","dateComplaintFiled":"06/30/2008","vin":"YV1RS59V642","components":"ENGINE AND ENGINE COOLING,ELECTRICAL SYSTEM","summary":"I HAVE A 2004 VOLVO S60 WITH 57,700 MILES. ALL WORK ON THE VEHICLE HAS BEEN DONE BY VOLVO.  RECENTLY, WHEN THE AC IS ON, THE FAN SPEED HAS STOPPED RESPONDING TO ADJUSTMENTS.  NOTHING HAPPENS WHEN I TRY TO ADJUST THE SPEED AND THEN, ON ITS OWN, THE SPEED WILL CHANGE A FEW MINUTES LATER.  WHEN I TURN THE CAR OFF, THE FAN CONTINUES TO RUN FOR AT LEAST FIVE MINUTES. I'M AFRAID THAT ONE DAY IT WON'T TURN OFF AND WILL DRAIN THE BATTERY. THE VOLVO REP AND AN INDEPENDENT MECHANIC FEEL THAT THE REPAIR MAY BE COSTLY AND JUST TO DO THE DIAGNOSTIC IS EXPENSIVE, SO I HAVEN'T HAD IT DONE WHILE I DECIDE WHETHER TO JUST TRADE IN THE VEHICLE.   *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10230386,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/05/2008","dateComplaintFiled":"06/09/2008","vin":"YV1RS59V342","components":"SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING,VISIBILITY,EQUIPMENT","summary":"2004 VOLVO S60 2.5T.  PURCHASED THE CAR USED IN SEPT 07.  6-5-08 PANEL DISPLAYED OPEN REAR DOOR WHILE DRIVING 65MPH ON HIGHWAY,  MY DOOR WAS NOT OPENED.  CAR JERKED AS IF THERE WAS POWER LOSS, AC WENT OFF, BRAKE FAILURE LIGHT ON PANEL, POWER WINDOWS AND LOCKS DID NOT WORK, TEMP 105 , THEN DRIVER PANEL WENT BLACK.  CAR JERKED 3 TIMES IN MID TRAFFIC, I WAS SCARED TO DEATH FOR MY LIFE.  ARRIVED AT MY EXIT, PULLED OVER TO A GAS STATION,  ENGINE STILL RUNNING BUT SLUGGISH, RADIO WAS STILL ON, POWER DOOR LOCKS AND WINDOWS DID NOT WORK, AC OFF.  ENGINE STILL RUNNING SO I MADE IT A COUPLE OF MILES UP THE STREET TO MY HOME.  CUT THE CAR OFF AND BACK ON, ALL POWER RETURNED, NOW CHECK ENGINE AND AIR BAG TROUBLE ON PANEL.  WENT TO VOLVO DEALER  NEXT DAY 6-6-08 NEAR MY HOME, THEY CAN NOT SEE MY CAR TIL NEXT WEEK TUESDAY.  WENT TO PEPBOYS, BATTERY AND ALTERNATOR ARE OK, CAN NOT ACCESS ENGINE BOX, MUST GO TO DEALER.  CALLED VOLVO FOR TUESDAY 6-10-08  APPOINTMENT.  CAR DUPLICATED SAME PROBLEM MONDAY 6-9-08 ON DRIVE HOME FROM WORK ON THE HIGHWAY TEMP 105 ETC.  SEARCHED FOR COMPLAINTS AND RECALLS, MY RECALLS WERE REPORTED COMPLETED WHEN I PURCHASED THE CAR, FOUND ALL OF THIS VALUABLE INFO ONLINE, WILL SEE DEALER TOMORROW AND TAKE THESE RELATED COPIES OF COMPLAINTS WITH ME.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10225299,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/15/2008","dateComplaintFiled":"04/21/2008","vin":"","components":"FUEL SYSTEM, OTHER","summary":"WHILE FUELING THE VEHICLE, GASOLINE BUBBLES UP AND OUT THROUGH THE FILLER NECK, LEAVING A LARGE PUDDLE OF GASOLINE ON THE GROUND.  THIS GENERALLY HAPPENS WHEN THE TANK IS LESS THAN HALF FULL.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10219593,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/14/2008","dateComplaintFiled":"02/28/2008","vin":"YV1RH59H642","components":"FUEL SYSTEM, GASOLINE","summary":"I OWN A 2004 VOLVO S60. I RECENTLY FOUND OUT THAT THERE IS A RECALL ON MY VEHICLE AFTER MY MECHANIC TOLD ME MY CHECK ENGINE LIGHT WAS DUE TO THIS RECALL. VOLVO SAYS THERE IS NO SUCH RECALL AT FIRST, BUT UPON CALLING THE CUSTOMER SERVICE NUMBER I FOUND OUT THAT THERE IS. HOWEVER, THEY SAY IT IS VIN SPECIFIC AND THAT MINE IS NOT COVERED. MY MECHANIC SAYS THAT THIS NEEDS TO BE TAKEN CARE OF, FOR THIS PROBLEM CAN CAUSE MY ENGINE TO STALL OUT AT ANYTIME AND CAUSE MY STEERING WHEEL TO JERK AROUND ON THE HIGHWAY. TO ME, THIS IS A HUGE PROBLEM, SOUNDS LIKE THAT IT COULD POTENTIALLY KILL ME ON THE ROAD. HOW CAN SOMETHING THAT CAN BE THIS POTENTIALLY DANGEROUS NOT BE VOLVOS RESPONSIBILITY TO FIX? JUST BECAUSE MY VIN NUMBER IS DIFFERENT DOES NOT MEAN THE PROBLEM IS ANY LESS SERIOUS, THOUGH VOLVO SEEMS TO THINK IT IS.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10219289,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/25/2008","dateComplaintFiled":"02/27/2008","vin":"YV1RS59V542","components":"TIRES","summary":"FRONT TIRES ARE RUBBING THE BODY ON THE INSIDE OF THE TIRE. VEHICLE HAS ORIGINAL WHEELS AND TIRES. CHRONIC PROBLEM WITH VOLVO.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10219547,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"02/22/2008","dateComplaintFiled":"02/27/2008","vin":"YV1RS64A142","components":"SERVICE BRAKES, HYDRAULIC,ENGINE AND ENGINE COOLING","summary":"I WAS LEAVING UCLA PARKING GARAGE (I'M AN RN THERE) WHEN I PUT MY VOLVO 2004 S60 INTO GEAR AND IT TOOK OFF BACKWARDS LIKE A ROCKET, CAR WAS THROWN INTO A CONCRETE POST FAR AWAY FROM WHERE I BEGAN. I IMMEDIATELY PUT CAR IN PARK SINCE I THOUGHT I'D GET OUT AND SEE WHAT ON EARTH HAPPENED, BUT IT THEN LUNGED FORWARD BY ITSELF AND TOOK OFF WITHOUT STOPPING!!! THANK GOD IT WAS 6PM AND NOT AN HOUR EARLIER WHEN MANY STAFF WOULD HAVE BEEN IN GARAGE, I'D HAVE RUN THEM OVER! I ALSO TURNED OFF IGNITION WITH KEY, NOTHING HELPED!! IT KEPT GOING ALONG WITH A MIND OF ITS OWN AT APPROX 15 MPH MAKING A GROWLING WHIRRING SOUND. I WAS ABLE TO STEER CAR AND AVOID OTHER VEHICLES BUT EVENTUALLY HAD TO MAKE SERIOUS DECISION TO PURPOSELY CRASH INTO ANOTHER CONCRETE MASSIVE POST WHICH I DID AND THE \"POSSESSED BEAST\". FINALLY CAME TO A HALT WITH FLUID POURING OUT ALL OVER,.   MY BRAKES DID NOT WORK DURING THIS EVENT, NOT AT ALL, THAT'S WHY I COULDN'T STOP THE CAR (ALONG WITH FOOT ON BRAKE, TRIED PUTTING CAR IN PARK GEAR AND TURNED OFF IGNITION KEY  LAST AUGUST WHEN I HAD ONLY 22, 000 MILES ON CAR IT TOOK IT TO VOLVO DEALER TWICE, SINCE CAR WAS OFTEN STALLING AND STOPPING ON THE STREET WHILE I WAS DRIVING. I WAS TOLD THEY COULDN'T FIND IT STALLING WHEN THEY TEST DROVE IT  BUT THEY MENTIONED THEY CLEANED THE THROTTLE AND SAID THAT COULD HELP (WHICH IT DID UNTIL 2, 500 MILES LATER WHEN THIS HAPPENED. I HAVE DEALER PAPERWORK INDICATING CAR STALLING AND THAT THEY CLEANED THROTTLE BOX ALSO, THEY SAID I SHOULD BE TAKING CAR ON THE FREEWAY MORE AT HIGH ENOUGH SPEED TO \"BLOW OFF THE CARBON\"  I SPENT FRIDAY NIGHT IN ER WITH NECK/SHOULDER INJURIES, BUT THIS COULD HAVE BEEN A DISASTER. FORGOT TO MENTION THAT WHEN I TOOK CAR IN FOR SERVICE JULY 2007 DEALER REPLACED FUEL PRESSURE SENSOR AS PER RECALL. DON'T KNOW IF THIS IS SIGNIFICANT. ALSO WROTE ON FORM \"DURING INSPECTION FOUND UPPER ENGINE MOUNT COLLAPSED, CAUSE........ ENGINE REPAIR\".    UPDATED 03-25-08 *BF  THE DEALER STATED REAR BRAKE PADS HAD TO BE REPLACED. UPDATED 03/25/08  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10218252,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/17/2008","dateComplaintFiled":"02/17/2008","vin":"","components":"FUEL SYSTEM, OTHER","summary":"I HAVE HAD THE SAME PROBLEM OF THE CAR STALLING AROUND TURNS AND ON ABRUPT STOPS.  IT SEEMED TO FIRST BE RESOLVED BY THE RECALL OF THE PRESSURE SENSOR.  RECENTLY THOUGH THE CAR HAS BEEN STALLING SOMETIMES 5 TIMES PER DAY WHEN DOING THE SAME.  THE DEALER CLAIMS IT IS A PVC PROBLEM THAT NEEDS TO BE CLEANED AND WANTS TO CHARGE $1000 DOLLARS TO DO IT.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10217087,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/05/2008","dateComplaintFiled":"02/06/2008","vin":"","components":"ENGINE AND ENGINE COOLING","summary":"I OWN A 2004 VOLVO S60 2.5T AND RECENTLY HAD PROBLEMS WITH THE ENGINE STALLING IN THE MIDDLE OF A BUSY ROAD.  THIS CONCERNS ME BECAUSE OF THE HIGH RISK OF BEING INVOLVED IN A MAJOR ACCIDENT.  I'M WORRIED THIS MAY HAPPEN AGAIN.  I'VE CONTACTED MY DEALER (PHILLIPS VOLVO 4980 VIRGINIA BEACH BOULEVARD, VIRGINIA BEACH, VA 23462) AND THEY INFORMED ME I DO NOT HAVE A RECALL ON MY VEHICLE.  I AM STILL TAKING MY CAR TO THE MECHANIC TO SEE WHAT THE PROBLEM MAY BE.  I'VE HAD A \"CHECK ENGINE\" LIGHT ON AND OFF FOR MANY MONTHS NOW, THE DEALERSHIP HAS CHECKED THIS OUT AND SAID I HAVE NO ERRORS AND MY CAR IS FINE.  I AM VERY UNCOMFORTABLE WITH THIS DIAGNOSIS.    *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10214545,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/07/2008","dateComplaintFiled":"01/11/2008","vin":"YV1RH52YX42","components":"FUEL SYSTEM, GASOLINE","summary":"STRONG FUEL SMELL COMING FROM INSIDE VEHICLE.  FUEL PUMP LEAKING.  THE DEFECT WAS NOTED ON 2001-2002 MODEL YEARS BUT NEEDS TO BE EXTENDED TO 2004 FOR VEHICLES IN NEVADA.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10214467,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/26/2007","dateComplaintFiled":"01/10/2008","vin":"YV1RS59V742","components":"POWER TRAIN","summary":"WHEN ACCELERATING FROM A STOP, THE TRANSMISSION SEEMS TO SKIP A GEAR. THIS RESULTS IN UNEVEN ACCELERATION, MAKING MERGING INTO TRAFFIC HAZARDOUS. IT ONLY HAPPENS SPORADICALLY.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10208579,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/29/2007","dateComplaintFiled":"11/10/2007","vin":"YV1RH52YX42","components":"FUEL SYSTEM, GASOLINE","summary":"STRONG FUEL ODOR EMITTING FROM PASSENGER SIDE OF VEHICLE.  OBSERVED GAS STAINS COVERING OUTSIDE OF GAS TANK.  RETURNED TO DEALER AND DEALER REPLACED FUEL PUMP.  SINCE THEN, NO ODORS.  HOWEVER, AUTO CONTINUES TO HESITATE WHEN DRIVING.  IN ONE INSTANCE, CAR STALLED IN HEAVY TRAFFIC AND WAS NEARLY REAR ENDED. *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10207410,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/25/2007","dateComplaintFiled":"10/30/2007","vin":"YV1RS61T042","components":"ENGINE AND ENGINE COOLING","summary":"CARS SHUT OFF ON TWO SEPARATE OCCASIONS WITH OUT A MOMENTS NOTICE WITHIN A TWO WEEK PERIOD, ONCE AT A STOP SIGN ANOTHER TIME IN STOP AND GO TRAFFIC ON A MAJOR HIGHWAY. I HAVE ONLY OWNED THIS CAR FOR LESS THAN TWO MONTHS. THERE ARE NO SIGNALS OR CODES LISTED ON THE CAR AS TO WHY IT SHUT OFF. CAR DOESN'T HAVE PROBLEM RESTARTING AT ALL. VOLVO DEALER HAS LISTED THIS CAR AS UP TO DATE WITH ALL RECALLS. ISSUE IS YET TO BE RESOLVED, DUE TO MECHANIC'S NOT EXPERIENCING THE SHUT OFF POINT THEY ARE FAILING TO DIAGNOSE THE SITUATION PERIOD. MY SAFETY IS 1ST, HOWEVER MY CAR MAY SHUT OFF AT ANY POINT, SO I DO NOT FEEL SAFE IN THIS CAR AT ALL.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10204924,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/05/2007","dateComplaintFiled":"09/27/2007","vin":"YV1RS59VX42","components":"STEERING,ENGINE AND ENGINE COOLING","summary":"LTR RE 2004 VOLVO S60 2.5 T STEERING DEFECT; SEEKING STEERING OF MY VEHICLE BE CORRECTED, RE-ENGINEERED TO THAT OF ANY CURRENT VOLVO SEDAN; PLEASE CONTACT HER BY MAIL OR PHONE WITHIN 14 DAYS OF THIS LETTER.  *KB  THE CONSUMER STATED THE TIRES WERE RUBBING AGAINST THE STEERING WELL WHEN MAKING TURNS.  THE DEALER PERFORMED A TEMPORARY FIX BY INSTALLING A STEERING RACK LIMITER TO PREVENT THE TIRE RUBBING. THE CONSUMER CALLED THE DEALER BACK ONCE THE PROBLEM RETURNED AND WAS THEN INFORMED THAT THERE WAS A STEERING ENGINEERING DEFECT WITH THE VEHICLE AND THE MANUFACTURER WAS OFFERING A STEERING REPLACEMENT KIT THAT COULD BE INSTALLED AT NO COST. ONCE THE REPLACEMENT KIT WAS INSTALLED, THE CONSUMER SOON DISCOVERED THE STEERING RADIUS WAS INCREDIBLY DIMINISHED AND THAT SHE COULD NO LONGER MAKE U-TURNS AT AN INTERSECTION. THE DEALER TOLD THE CONSUMER THE STEERING KIT WAS THE ONLY SOLUTION THAT VOLVO OFFERED. THE CONSUMER STATED THE COOLANT LIGHT WAS ON.  THE DEALER STATED THE RADIATOR WAS LEAKING. *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10202609,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/10/2007","dateComplaintFiled":"09/04/2007","vin":"YV1RS61T442","components":"ENGINE AND ENGINE COOLING","summary":"2004 VOLVO 60 SERIES ENGINE SHUTS OFF WHILE DRIVING.*KB  THE CONSUMER STATED SHE RECEIVED A RECALL IN THE MAIL DESCRIBING THE SAME PROBLEM THAT SHE EXPERIENCED. *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10201715,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/30/2007","dateComplaintFiled":"09/02/2007","vin":"YV1RH59H742","components":"ENGINE AND ENGINE COOLING","summary":"I HAVE A 2004 VOLVO S60. IN THE PAST ONE YEAR IT KEEPS STALLING BOTH IN MOTION AND WHEN GOING INTO DRIVE FROM PARK. THIS CREATES A DANGEROUS SITUATION WHILE OPERATING THE VEHICLE, ESPECIALLY WHEN IN MOTION AT HIGHWAY SPEEDS. I HAVE TAKEN THE VEHICLE TO VOLVO AUTHORIZED SERVICE TWICE WITH NO RESOLUTION. THE LAST STALL WAS ON AUGUST 30, 2007 RESULTING IN THE CAR BEING TOWED TO VOLVO SERVICE. A RECALL WAS ISSUED ON 2004 S40 DUE TO A SIMILAR COMPLAINT, BUT I WAS TOLD THAT THE RECALL DID NOT APPLY SINCE THE VEHICLE WAS AN ALL WHEEL DRIVE.  *TR","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10197082,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/07/2004","dateComplaintFiled":"07/20/2007","vin":"YV1RH52Y142","components":"ENGINE AND ENGINE COOLING","summary":"TL*THE CONTACT OWNS A 2004 VOLVO S60.  WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER STEERING AND THE BRAKES FAILED.  THE CONTACT SHIFTED INTO NEUTRAL AND THEN TURNED OFF AND RESTARTED THE VEHICLE.  THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE.  THE CURRENT MILEAGE IS 32,000 AND FAILURE MILEAGE WAS 7,800.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10196178,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/11/2007","dateComplaintFiled":"07/12/2007","vin":"YV1RS59V142","components":"TIRES","summary":"I OWN A VOLVO S60 AND HAVE UNDER 30,000 MILES ON THE VEHICLE.  YESTERDAY I SUFFEREDTHE  SECOND BLOW OUT ON THE  CONTINENTAL CONTITOURING CONTACT TIRES,  215/55R16 93H CH95.  I AM CONCERNED FOR MY SAFETY AND THE SAFETY OF OTHERS AS THESE TIRES APPEAR TO BE DEFECTIVE WITH TWO BLOW OUTS IN UNDER 30,000 MILES.  THE TIRES ARE RATED TO 60,000 MILES.  *AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Tire","productYear":"9999","productMake":"CONTINENTAL","productModel":"CONTITOURING","size":null,"manufacturer":"Continental Tire the Americas, LLC"}]},{"odiNumber":10193701,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/06/2007","dateComplaintFiled":"06/19/2007","vin":"YV1RS59V642","components":"VEHICLE SPEED CONTROL","summary":"ON 1/6/07 I WAS TRAVELING VIA INTERSTATE WHEN THE 2004 VOLVO S60T EXPERIENCED WHAT WAS DISPLAYED ON THE SCREEN AS REDUCED ENGINE PERFORMANCE,  AND QUICKLY SLOWED TO ABOUT 40 MPH. I WAS VERY NEARLY REAR-ENDED AS I WAS IN THE FAST LANE IN THE PROCESS OF PASSING A SLOWER VEHICLE. I PROCEEDED TO THE NEAREST EXIT AND COASTED INTO A GAS STATION. I TURNED OFF THE CAR AND TRIED TO RESTARTED IT.  HOWEVER, IT  MADE A LOUD  NOISE, SHOOK, AND THEN FAILED TO CRANK. IT WAS TOWED TO THE NEAREST VOLVO DEALERSHIP, WHERE THEY INFORMED ME IT WAS A FAULTY THROTTLE BODY (ETM).  THE CAR ONLY HAD 58,000 MILES , 8,000 OUT OF WARRANTY. THE REPAIRS INCLUDED REMOVING AND CLEANING THE ETM, REPLACING THE THROTTLE BODY, AND ETM SOFTWARE RELOADED FOR A TOTAL OF $14,000. 3 MONTHS LATER, WHILE I WAS IN THE HOSPITAL GIVING BIRTH, MY HUSBAND EXPERIENCED THE SAME MALFUNCTION ON THE WAY TO THE HOSPITAL, LOST POWER, AND HAD TO GET ALTERNATE TRANSPORTATION. WE TRADED THE CAR IMMEDIATELY WITHOUT REPAIR.  *AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10185603,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"03/12/2007","dateComplaintFiled":"03/20/2007","vin":"YV1RH52Y842","components":"AIR BAGS","summary":"ON MARCH 12 MY VOLVO S-60R WAS T-BONED\"BY A LARGE SUV ORD EXPLORER THAT IMPACTED A POINT NEAR MY FRONT DRIVER'S-SIDE WHEEL. THE SUV IMPACT CAUSED MAJOR DAMAGE TO THE FRONT END BY TOTALLY REMOVING THE VOLVO'S BUMPER AND MANGLING THE FRONT DRIVER QUARTER PANEL DOWN TO THE CHASSIS. ALTHOUGH MY CAR WAS SENT SPINNING BY THE FORCE OF THE COLLISION.  NONE OF THE AIRBAGS DEPLOYED AT THIS INITIAL IMPACT. AS MY VOLVO PROCEEDED TO SPIN CLOCKWISE ACROSS THE PAVEMENT  IT IMPACTED THE OVER PASS GUARD-RAIL SUCH THAT THE DRIVER'S SIDE SLAMMED INTO THE GUARD-RAIL, PINNING ME IN THE VEHICLE. ONLY THE PASSENGER FRONT AIRBAG DEPLOYED ON HITTING THE GUARD RAIL  AND RELEASING MUCH SMOKE INTO THE CABIN.  EVEN THOUGH THIS WAS AN ABRUPT, VIOLENT IMPACT , BOTH WHEN THE SUV HIT ME, AND WHEN MY CAR SLAMMED INTO THE GUARD RAIL THE ONLY COMPONENT OF THE AIRBAG/COLLISION CURTAIN SYSTEM TO FUNCTION WAS THE DASHBOARD INSTALLED PASSENGER AIR BAG. IT IS  IMPORTANT TO NOTE THAT THERE WAS NO OTHER PERSON TRAVELING IN THE VOLVO BUT ME. THE FRONT PASSENGER SEAT AND THE REAR SEATS- WERE EMPTY. WITHIN ABOUT 12 HOURS OF THE ACCIDENT I WROTE VOLVO AMERICA TO EXPRESS MY EXTREME DISSATISFACTION  WITH THE FAILURE OF THE CAR'S SAFETY SYSTEM.*AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10184546,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"03/06/2007","dateComplaintFiled":"03/08/2007","vin":"YV1RS61T142","components":"FUEL SYSTEM, GASOLINE","summary":"I HAVE A VOLVO S60 2004.  AROUND JANUARY 2007, IT STARTED STALLING WITHOUT WARNING IN THE MIDDLE OF THE HIGHWAY AT 60 MPH.  IT DID THIS ABOUT 3 TIMES IN 2 WEEKS, SO I TOOK IT TO THE VOLVO DEALER.  THEY COULDN'T REPRODUCE THE PROBLEM, BUT SUPPOSEDLY UPGRADED THE SOFTWARE AND CLEANED THE THROTTLE INTAKE, AND RETURNED THE CAR TO ME.  THE CAR WAS FINE UNTIL MARCH 6, WHEN THE SAME PROBLEM OCCURRED.  THE CAR IS CURRENTLY BACK AT THE SHOP WHERE THEY HAVE TOLD ME THEY HAVE FOUND NOTHING WRONG AND ARE GOING TO RETURN THE CAR TO ME.  I WOULD NOT LIKE TO GET KILLED ON THE HIGHWAY, AND AS I HAVE SEEN THAT THIS HAS BEEN REPORTED BEFORE ON OTHER INTERNET SITES, ITS WORTH REPORTING HERE. *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10183806,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/25/2007","dateComplaintFiled":"02/28/2007","vin":"YV1RS61TX42","components":"VEHICLE SPEED CONTROL","summary":"TL*-  WHILE PARKING  THE  2004 VOLVO S60 IN THE DRIVEWAY THE VEHICLE SUDDENLY LURCHED FORWARD, CAUSING THE FRONT WHEELS TO GO OVER A CEMENT BLOCK, HITTING THE HOUSE LIGHTLY.  SMOKE STARTED COMING FROM THE ENGINE, AND THE SERVICE ENGINE LIGHT ILLUMINATED ON THE DASHBOARD.  THE CONTACT HAD THE VEHICLE TOWED TO A BODY SHOP SINCE THERE WAS SOME SLIGHT DAMAGE IN THE FRONT OF THE VEHICLE.  CONTACT COULD PROVIDE PICTURES IF NEEDED.   THE CURRENT AND FAILURE MILEAGE WERE BOTH 26800.*AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10182906,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/14/2007","dateComplaintFiled":"02/18/2007","vin":"YV1RH52YX42","components":"TIRES","summary":"2004 VOLVO S60 R WITH 18\" TIRES. INSIDE DRIVER TIRE CONTACTS INSIDE DRIVER TIRE WALL. WEAR WILL CAUSE PREMATURE TIRE FAILURE. DEALER HAS ALWAYS MAINTAINED THAT THIS \"RUBBING\" IS NOT A PROBLEM. I HAVE COMPLAINED MULTIPLE TIMES.   I HAVE PHOTOS OF THE TIRE DAMAGE. THE SIDE WALL AND CORNER TREAD IS WORN THROUGH TO THE STEEL BELT AND CORD. I HAVE BEEN TOLD THAT THIS IS NOT DUE TO ALIGNMENT, BUT MATCHES UP WITH THE RUBBING OF THE TIRE WELL WALL. *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10178026,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/07/2007","dateComplaintFiled":"01/07/2007","vin":"YV1RH59H242","components":"SEAT BELTS,CHILD SEAT","summary":"IN REGARD TO A 2004 S60 VOLVO 2.5 AWD-T WE NOTICED A SEAT BELT PROBLEM WITH THE BACK SEAT CENTER SEAT BELT.  WE SECURED OUR INFANT CAR SEAT BASE WITH THE CENTER SEAT BELT, AND HAVE BEEN DOING SO SINCE SHE WAS BORN.  THE LOCAL POLICE STATION HAD A SERVICE THAT DEMONSTRATED PROPER INSTALLATION AND INSURED WE WERE ABLE TO DO IT OURSELVES.  THE OFFICER THEN INSTALLED IT FOR US WITH NO PROBLEM.  TODAY WE NOTICED THE BASE WAS REALLY LOOSE!  I TRIED TO REINSTALL THE SEAT BY ATTACHING IT TO THE SEAT BELT IN THE USUAL FASHION.  HOWEVER, I DISCOVERED THAT THE SEAT BELT DID NOT HOLD THE BASE TIGHTLY AS IT DID BEFORE!!!  IN SUMMARY-  NORMAL USE LED UP TO THE FAILURE OF THE THREE POINT SAFETY BELT IN THE REAR CENTER SEAT POSITION TO PROPERLY HOLD THE BASE OF AN INFANT CAR SEAT SAFELY.  WE ARE GOING TO CALL THE DEALER FIRST THING IN THE MORNING AND HAVE IT FIXED.  *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Child Seat","productYear":"9999","productMake":"UNKNOWN","productModel":"UNKNOWN","manufacturer":"UNKNOWN MANUFACTURER"}]},{"odiNumber":10175490,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"12/05/2006","dateComplaintFiled":"12/07/2006","vin":"","components":"POWER TRAIN","summary":"THE GEAR SHIFT HEAD DISINTEGRATED IN MY HAND AS I SHIFTED FROM PARK INTO DRIVE CAUSING THE VEHICLE UNABLE TO BE SHIFTED INTO ANY GEAR BUT \"DRIVE\".  COULD NOT TURN OFF THE VEHICLE, BUT WAS ABLE TO DRIVE INTO THE NEAREST VOLVO DEALER.  CONSEQUENCES COULD HAVE BEEN DIRE IF I HAD TO STOP FOR A ROAD/POLICE EMERGENCY.  *NM","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10172870,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/29/2006","dateComplaintFiled":"11/07/2006","vin":"YV1RS61T142","components":"STRUCTURE","summary":"I WAS DRIVING MY 2004 VOLVO S60 ON THE NJ TURNPIKE.  WINDS REPORTED THAT DAY TO BE UP TO 50 MPH AND I AM DRIVING AT AROUND 50 TO 60 MPH WHEN I HEARD A LOUD SOUND FROM THE REAR OF MY CAR.  I STARTED TO SLOW DOWN TO ENTER ONTO THE BREAKDOWN LANE ON THE TURNPIKE DRAGGING THE BUMPER AS I PULLED OVER.  WHEN I GOT OUT TO INSPECT I FOUND THAT MY BUMPER COVER HAVE BLEW OFF OF THE CAR AND WAS HANGING ON DUE TO A WIRE THAT WAS CONNECTED TO IT ON THE RIGHT SIDE.  I CALLED MY VOLVO DEALER AND WAS OFFERED AN APPT TO BRING IT IN.  THE SERVICE MANAGER ALONG WITH HIS REGIONAL REP IS DISPUTING THAT THIS COULD HAVE HAPPENED.  THEY ARE SAYING THAT THEY HAVE NEVER HEARD OF THIS BEFORE AND THAT IT COULD NOT HAVE HAPPENED BECAUSE IT HAS NEVER HAPPENED AND WILL NOT TAKE RESPONSIBILITY FOR THE REPLACEMENT UNLESS IT IS PAID FOR BY ME.  NEITHER THE DEALER OR THE REP IS CONCERNED ABOUT THE SAFETY OF THIS INCIDENT AND WHY THIS ACTUALLY HAPPENED.  IT IS BY THE GRACE OF GOD THAT THIS BUMPER COVER DID NOT COMPLETELY DISLODGE CAUSING  FATALITIES TO OCCUR HAD THE WIND BLEW IT IN THE PATH OF OTHER CARS ON THE ROADS.  NOT ONLY AM I NOT GETTING GOOD SERVICE VOLVO IS NOT CONCERNED ABOUT SAFETY WHICH IS THE CORE OF THEIR COMMITMENT TO THE CONSUMERS.  MY CHARACTER AND MY INTEGRITY AND CREDIBILITY IS BEING CHALLENGED BY THE SERVICE MANAGER AND HIS REGIONAL REP RATHER THE REASON FOR THE BUMPER COMING OFF IN THIS WAY.  MY CONFIDENT IN THE SAFETY OF THE CAR AND VOLVO CUSTOMER SERVICE HAS BEEN DESTROYED.  VOVLO IS SAYING THAT THIS IS THE FIRST TIME THEY HAVE HEARD OF A BUMPER BLOWING OFF.  THERE IS ALWAYS A FIRST AND BEING THE FIRST DOES NOT INDICATED THAT IT'S IMPOSSIBLE TO HAVE HAPPENED.  *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10169423,"manufacturer":"Volvo Car USA, LLC","crash":true,"fire":false,"numberOfInjuries":1,"numberOfDeaths":0,"dateOfIncident":"09/18/2006","dateComplaintFiled":"09/27/2006","vin":"YV1RS59V542","components":"FUEL SYSTEM, GASOLINE","summary":"ON SEPTEMBER 18 I WAS TRAVELING DOWN INTERSTATE 10 WHEN MY 2004 VOLVO S60 COMPLETELY STOPPED RUNNING WHILE GOING 70 MPH.  I WAS UNABLE TO GET THE CAR OUT OF THE TRAFFIC (NO POWER TO DRIVE TO THE SHOULDER).  MY CAR WAS COMPLETELY USELESS.  I CALLED 911 AND ROADSIDE ASSISTANCE TO GET HELP BEFORE I WAS HIT (I WAS UNABLE TO EXIT THE VEHICLE DUE TO MOVING TRAFFIC ON EITHER SIDE OF ME).  AFTER 50 MINUTES I WAS HIT IN THE REAR.  THE VEHICLE WAS TOWED TO BERGERON VOLVO.  I WAS INFORMED THAT THE FUEL PUMP HAD FAILED.  THERE WAS NO WARNING AND THE VEHICLE HAD JUST BEEN IN FOR SERVICE 1 MONTH BEFORE.  IT ONLY HAS 24,000 MILES.   *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10160822,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/22/2006","dateComplaintFiled":"06/26/2006","vin":"YV1RH59H342","components":"TIRES","summary":"TIRES SIDEWALLS.  *NM","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Tire","productYear":"9999","productMake":"PIRELLI","productModel":"P6","size":null,"manufacturer":"Pirelli Tire, LLC"}]},{"odiNumber":10156519,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/19/2006","dateComplaintFiled":"05/01/2006","vin":"YV1RH59H242","components":"ELECTRICAL SYSTEM","summary":"CAR STOPS WHILE DRIVING.  GAUGES ON DASHBOARD DON'T WORK.  *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10155772,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/07/2006","dateComplaintFiled":"04/20/2006","vin":"","components":"POWER TRAIN","summary":"2004 S60AWD ANGLE GEAR LEAK REQUIRED REPLACEMENT OF GEAR AT 14,300 MILES.  THE ANGLE GEAR SENDS POWER TO THE REAR WHEELS, AND IF IT FAILS, IT TAKES THE TRANSMISSION WITH IT.  WHILE MINE WAS CAUGHT EARLY AND REPLACED UNDER WARRANTY, A TRACK RECORD OF THE ANGLE GEAR LEAKING AND FAILING  IS BEING SEEN.  VOLVO NEEDS TO EXTEND WARRANTY ON THIS ITEM.  *NM","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10150235,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/11/2004","dateComplaintFiled":"02/14/2006","vin":"","components":"SUSPENSION","summary":"LOUD NOISE FROM REAR WHEELS.  FIRST THOUGHT TO BE WORN TIRES.  TURNED OUT TO BE THE BEARINGS FAILED.  CAUSED DAMAGE TO SPEED SENSOR, ROTOR, REAR AXLE DRIVE SHAFT.  CAR SHOOK VIOLENTLY AS SPEEDS WHERE REDUCED.  DEALER WILL NOT FIX PROBLEM.  ALL PARTS TO BE REPLACED AT OWNERS EXPENSE.  *NM","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10149150,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/30/2006","dateComplaintFiled":"01/31/2006","vin":"YV1RS61T542","components":"STEERING,SUSPENSION","summary":"DT*:  THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS AND TURNING LEFT OR RIGHT THE TIRES TOUCHES THE FRAME OF THE VEHICLE.  THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION ON FOUR OCCASIONS.  THE FIRST TIME THE DEALER PLACED STEERING BLOCKS ON THE VEHICLE. THE SECOND, THIRD AND FOURTH TIMES THE DEALER ADJUSTED THE CONTROL ARMS.  HOWEVER NONE OF THESE EFFORTS REMEDIED THE PROBLEM.  THE PROBLEM CONTINUES AND THE VEHICLE HAS NOT BEEN RETURNED TO THE DEALER FOR FURTHER DIAGNOSTIC TESTING.  UPDATED 2/24/2006 - POWER STEERING RESERVOIR LEAKED FLUID FROM THE BOTTOM HOSE NEAR THE CLAMP.  THE CONSUMER HEARD A METAL ON METAL SOUND WHILE TURNING THE WHEEL.   THE DEALER MODIFIED THE STEERING STOPS.  AL FOUR TAILLIGHT AND BOTH LOW BEAM BULB WENT OUT.   *NM","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10148506,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/11/2006","dateComplaintFiled":"01/24/2006","vin":"","components":"POWER TRAIN","summary":"VOLVO S60 2004, 9000 MILES, AUTOMATIC TRANSMISSION.  WHILE LEAVING A TRAFFIC LIGHT (ACCELERATING) AND AT A SPEED OF ABOUT 20 MPH THE ENGINE SUDDENLY STOPPED.  NO POWER FOR STEERING AND BRAKES. WHAT COULD HAPPEN IF THE DEFECT OCCURRED ON THE HIGHWAY? THE CAR WAS SERVICED AT VOLVO GARAGE ACCORDING TO MAINTENANCE PROGRAM (6000 MILES). NOW THEY SAID THAT THE DEFECT WAS  DUE TO THE AIR ADMISSION SYSTEM, WHICH WAS FOUND  TO BE DIRTY.  *AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10131117,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"06/15/2005","dateComplaintFiled":"08/02/2005","vin":"YV1RS64A142","components":"ENGINE AND ENGINE COOLING","summary":"DT:  CONSUMER OWNED A 2004 VOLVO S60. ON GOING SINCE APRIL OF 2005 ENGINE REBUILT DUE TO STALLING. VEHICLE STALLED  IN TRAFFIC AND DID NOT ACCELERATE  PROPERLY. ALSO, VEHICLE SLOWED DOWN  AT ONCE FOR NO REASON. WHILE DRIVING AFTER THE ENGINE  WAS REBUILT AND WAS MERGING ONTO I87 NORTH AND VEHICLE  STALLED. CONSUMER  PULLED OFF THE RAMP ONTO THE SHOULDER. THEN PAUSED FOR ABOUT FIVE MINUTES TO REGAIN  COMPOSURE AND THEN RESTARTED ENGINE.  VEHICLE RESTARTED WITH NO PROBLEM. CONSUMER SAID  THAT STALL ONLY HAPPENED TWICE. DEALER  REPLACED MASS AIRFLOW SENSOR, BUT VEHICLE STILL DID NOT OPERATE CORRECTLY. CONSUMER THOUGHT THAT VEHICLE DID  NOT OPERATE PROPERLY BETWEEN 2000 AND 3000 RPMS. THE  MANUFACTURER SHOULD DO SOMETHING ABOUT THIS PROBLEM WHICH WAS  VERY DANGEROUS. CONSUMER  WORRIED ABOUT HER LIFE WHILE DRIVING VEHICLE.*AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10111747,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/12/2005","dateComplaintFiled":"04/25/2005","vin":"YV1RH59H942","components":"EXTERIOR LIGHTING","summary":"CONSUMER NOTICED THAT THE RIGHT FRONT HEADLIGHT LAMP WAS INOPERATIVE.  THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION.   THE MECHANIC INFORMED THE DRIVER THAT THE HEAD LAMP BLEW OUT AND NEEDED TO BE REPLACED.     IT WOULD COST THE CONSUMER $1,200.00 TO GET IT REPLACED.   PLEASE PROVIDE FURTHER DETAILS.   *NM  A PEBBLE FROM THE STREET MADE A SMALL HOLE IN THE GLASS IN FRONT OF THE HEADLAMP.  MOISTURE INTRUDED INTO THE LAMP CASING. DUE TOTHE HEAT INTENSITY OF THE LAMP, IT SHORT-CIRCUITED.  THE DESIGN OF THE HEAD LAMP SYSTEM DOES NOT ALLOW FOR THE SWIPE REPLACEMENT OF THE LAMP.  THE HOLE IN THE GLASS CAUSES NEED FOR THE ENTIRE $1200 SYSTEM TO BE REPLACED.  *BF","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10097591,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/25/2004","dateComplaintFiled":"10/25/2004","vin":"YV1RH59H042","components":"TIRES","summary":"DRIVER'S SIDE FRONT TIRE BLEW OUT WHILE TRAVELING AT 55 MPH.   DRIVER SIDE REAR TIRE WAS ALSO DEFECTIVE, IT HAD A BUBBLE ON THE SIDEWALL.*AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Tire","productYear":"9999","productMake":"PIRELLI","productModel":"P-600 TIRE","size":null,"manufacturer":"Pirelli Tire, LLC"}]},{"odiNumber":10096351,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"10/25/2004","dateComplaintFiled":"10/25/2004","vin":"","components":"TIRES","summary":"BOUGHT VOLVO S60 AWD FROM VOLVO OF DANBURY JULY 2004.  SEPTEMBER 1, 2004 NOTICED A BUBLE ON THE REAR DRIVERS SIDE TIRE. ON 10/25/2004 MY WIFE HAD A BLOW OUT ON I84 ON THE FRONT DRIVERS SIDE TIRE WHILE DRIVING ON A NEWLY PAVED HIGHWAY ROAD.  NEARLY INJURING HERSELF AND CARS AROUND HER ON THE 3 LANE HIGHWAY SHE BARELY MADE IT OVER TO THE BREAKDOWN LANE.  THE ENTIRE WALL OF THE TIRE WAS SEPERATE FROM THE REST OF THE TIRE ALL THE WAY AROUND.  THE TIRE IS A PIRELLI P6 FOURSEASONS TIRE. P235/45 R17. ONCE THE DOUGHNUT TIRE WAS PUT ON I IMMEDIATELY DROVE TO THE NEAREST VOLVO DEALER WHERE THE CAR WAS BOUGHT, AND THEY WOULD REPLACE THE TIRE BUT I WOULD HAVE TO PAY FOR BOTH TIRES AT A COST OVER 300 IN TOTAL. I STATED THAT THE CAR WAS BRAND NEW AND ONLY HAD 8K MILES, AND THEY SAID I WOULD NEED TO CONTACT PIRELLI.  I CALLED PIRELLI AND THEY SAID I WOULD NEED TO CONTACT AN AUTHORIZED DEALER FOR INSPECTION.  I CALLED THE AUTHORIZED DEALER AND THEY SAID THERE WAS NOTHING THEY COULD REPORT BECAUSE ALL WAS DUE TO ROAD HAZARDS. MY WIFE DID NOT HIT ANYTHING, THEREFORE THESE TIRES ARE NOT MADE FOR DRINVING ON NORMAL ROADS ESPECIALLY WITH ONLY 8K MILES ON THE TIRES.  I PUT A COMPLAINT INTO VOLVO CORPORTATE AND THEY HAVE NOT RETURNED MY CALL.  MY CONCERN IS FOR MY WIFES SAFETY AND THE FINANCIAL BURDEN OF REPLACING NEW TIRES ESPECIALLY IN A CAR THAT IS KNOWN FOR SAFETY, AND FOR THE AMOUNT OF MONEY WE PAID FOR THE CAR.  NO ONE IS TAKING RESPONSIBILITY AND VOLVO KEEPS PUTTING THESE TIRES ON THEIR CARS THAT ARE GOING TO CAUSE A SERIOUS ACCIDENT TO EITHER MY WIFE AND OR THE CARS THAT ARE DRIVING NEXT TO HER.*AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"},{"type":"Tire","productYear":"9999","productMake":"PIRELLI","productModel":"P6","size":null,"manufacturer":"Pirelli Tire, LLC"}]},{"odiNumber":10086915,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"08/07/2004","dateComplaintFiled":"08/15/2004","vin":"","components":"POWER TRAIN","summary":"TRANSMISSION FLARE.   *JB","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10079189,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/02/2004","dateComplaintFiled":"07/02/2004","vin":"","components":"SEATS","summary":"DRIVER'S SEAT ON 2004 VOLVO S60R UNEXPECTEDLY MOVES AFTER UNLOCKING CAR AND OPENING THE DRIVER'S DOOR.  VOLVO SAYS SYSTEM IS WORKING AS DESIGNED.  THEY SAY THAT THE SEAT MUST BE MOVED TO THE DESIRED POSITION WITH THE IGNITION TURNED ON.  IF IT IS MOVED WITH THE IGNITION OFF, IT WILL RETURN TO THE LAST POSITION IT WAS MOVED TO WITH THE IGNITION TURNED ON EVERY TIME THE CAR IS UNLOCKED.  THERE IS ALMOST A FOOT DIFFERENCE IN HEIGHT BETWEEN MY WIFE AND ME. SHE HAS OPENED THE LEFT REAR DOOR, PLACED ITEMS ON THE FLOOR BEHIND THE DRIVER'S SEAT THEN OPENED THE DRIVER'S DOOR, WHICH CAUSED THE DRIVER'S SEAT TO MOVE BACKWARDS TO MY POSITION CRUSHING THE ITEMS ON THE FLOOR.  I HAVE REPEATEDLY OPENED THE DRIVER'S DOOR AT NIGHT, HAD THE SEAT MOVE TO HER POSITION WITHOUT REALIZING IT, STEPPED IN AND HIT MY HEAD ON THE DOOR OPENING.  I'M BEING TOLD I HAVE TO GET INTO THE CAR WITH THE SEAT FORWARD, TURN ON THE IGNITION, THEN MOVE THE SEAT TO THE DESIRED POSITION TO PREVENT THE SYSTEM MALFUNCTION I HAVE DESCRIBED.  ONCE YOU ARE SITTING DOWN THE BUTTONS ON THE SIDE OF THE SEAT ARE HARD TO FIND, ESPECIALLY AT NIGHT.  THIS IS A COMPUTERIZED NIGHTMARE THAT COULD BE FIXED WITH A SOFTWARE UPGRADE IF VOLVO WERE MOTIVATED TO DO SO.  THE SAFE THING WOULD BE FOR THE SEAT TO STAY WHERE WE LEFT IT.  *AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10056530,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"02/04/2004","dateComplaintFiled":"02/04/2004","vin":"YV1RH52Y042","components":"ELECTRONIC STABILITY CONTROL","summary":"I RECENTLY PURCHASED A VOLVO S60R AUTOMOBILE FOR EAGLE VOLVO OF RIVERHEAD NY.  I RECEIVED THE S60 R IN EARLY DECEMBER AND AS OF TODAY (2-04-04) I HAVE APPROX 1750 MILES ON IT.  .*AK    SO WHY ALL THE DETAIL, WELL SINCE I HAVE OWNED THIS CAR IT HAS BEEN IN THE SHOP THREE (3) TIMES FOR A PROBLEM WITH THE 4C SUSPENSION SYSTEMS.  THE FIRST TIME IT SPENT APPROX A WEEK AT THE SHOP AND WAS TO BE RESOLVED WITH A SENSOR REPLACEMENT.  THE SECOND TIME WAS BECAUSE A SOFTWARE UPDATE WAS REQUIRED FOR THE SYSTEM, AND THE THIRD TIME THEY HAVE SPENT TWO DAYS ON IT AND ARE STILL NOT SURE WHAT THE ISSUE IS.    I HAVE BEEN VERY PATIENT OVER THIS PROBLEM.  I UNDERSTAND THESE THINGS HAPPEN, AND IF IT WHERE NOT FOR MY SALES PERSON WAYNE LAKE COMMITMENT TO ME I WOULD BE PROBABLY LOOKING FOR ANOTHER CAR.    THAT BEING SAID I AM VERY CONCERNED ABOUT THE LEVEL OF SERVICE I AM GETTING FROM VOLVO ITSELF.  EVEN AFTER I CALLED VOLVO CUSTOMER SERVICE TO ASK FOR SUPPORT IN THIS MATTER , I RECEIVED INFORMATION THAT A FIELD TECHNICIAN WOULD NOT BE ABLE TO COME OUT AND HELP IN THE RESOLUTION OF MY PROBLEM FOR TWO WEEK ( NEXT WEEK THEY ARE ALL GOING TO TRAINING) ..     TO HEAR THIS IS AN OUTRAGE.  I HAVE BEEN WITHOUT MY CAR FOR NEARLY 10 DAYS IN TOTAL; I HAVE LESS THE 2500 MILES, AND HAVE BROUGHT IT BACK TO THE SHOP THREE TIMES FOR THE SAME ISSUE AND EVEN AFTER ALL OF THIS VOLVO DOES NOT FEEL THAT THIS ISSUES WARRANTS A CHANGE IN SOMEONE\u0019S SCHEDULE OR THE NEED TO MAKE SOME ARRANGEMENTS TO GET MY CAR REPAIRED IN A TIMELY MANNER.    WORST YET , YOU WOULD THINK AFTER CALLING VOLVO CUSTOMER SERVICE AND OPENING UP A SO CALLED \u001cFOLDER\u001d THAT I WOULD RECEIVE A CALL EXPLAINING THE SITUATION OR WHAT WAS BEING DONE TO CORRECT THIS PROBLEM.  OR AT LEAST OFFERING MY SOME COMPENSATION FOR MY TROUBLES, LIKE A LONG TERM LOANER CAR TO REPLACE THE CAR I DO NOT HAVE DUE TO THIS ISSUE, OR MAYBE EVEN AN OFFER OF EXTENDING THE WARRANTY TO ADDRESS MY CONCERNS OVER THE RELIABILITY OF THE 4 C SUSPENSION.","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10057158,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"01/01/1901","dateComplaintFiled":"01/23/2004","vin":"","components":"SEATS","summary":"DUE TO THE SIZE OF THE HEAD RESTRAINTS AND THE WIDTH OF THE COLUMN  BETWEEN FRONT AND REAR WINDOWS, THE DRIVER HAS NO VISIBILITY TO THE REAR WHEN LOOKING OVER THE LEFT SHOULDER.   *PH  *NM","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]},{"odiNumber":10041096,"manufacturer":"Volvo Car USA, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"07/03/2003","dateComplaintFiled":"10/02/2003","vin":"YN1RH52Y442","components":"POWER TRAIN","summary":"VEHICLE WITH AUTOMATIC TRANSMISSION HAS A SERIOUS DESIGN FLAW THAT RESULTS IN A SERIOUS DELAY WHEN DECELERATING RAPIDLY.  THE DELAY MAKES IT SEEM AS THOUGH THE THROTTLE HAS \"STUCK\" FOR 2-3 TENTHS OF A SECOND.  THE \"R\" IS TOUTED AS A PERFORMANCE VEHICLE AND THIS DELAY IN THROTTLE RESPONSE IS DOWN RIGHT DANGEROUS WHEN THE VEHICLE IS DRIVEN HARD.  THIS DELAY OCCURS EVERY TIME ONE DECELERATES QUICKLY FROM FULL THROTTLE.  VOLVO SAYS IT IS \"NORMAL\".  *JB.  *AK","products":[{"type":"Vehicle","productYear":"2004","productMake":"VOLVO","productModel":"S60","manufacturer":"Volvo Car USA, LLC"}]}]}