{"count":1,"message":"Results returned successfully","results":[{"odiNumber":11733034,"manufacturer":"General Motors, LLC","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/22/2026","dateComplaintFiled":"04/22/2026","vin":"3GCUKREC7JG","components":"SUSPENSION,STRUCTURE,UNKNOWN OR OTHER","summary":"The frame of my 2018 Chevrolet Silverado 1500 has rusted through to the point of failing Maine state safety inspection at only 41,000 miles. A licensed Maine inspection station identified structural frame corrosion and determined the vehicle is unsafe to operate. A Chevrolet dealer confirmed the frame rust and stated the truck must have rusted sections cut out and welded to be made roadworthy. The vehicle is available for inspection upon request. Safety risk: A rusted-through frame on a pickup truck is a serious structural defect. Frame failure while driving could cause loss of vehicle control, separation of suspension or drivetrain components, or catastrophic structural collapse, particularly at highway speeds or under load. The vehicle is currently unregisterable in Maine due to this safety failure. The failure has been confirmed by both an independent licensed inspection station and by a Chevrolet dealership service department. This failure is consistent with a known manufacturing defect documented in GM Technical Service Bulletin 19-NA-255, which acknowledges that the wax coating applied to the frames of 2011\u20132024 Silverado and Sierra trucks was improperly applied by a third-party frame supplier, causing the coating to peel and exposing bare steel to premature corrosion. GM has issued this TSB but has not issued a recall, and Chevrolet dealers are not consistently performing the repair. I contacted GM Customer Assistance to request goodwill repair and was refused; the representative also declined to open a case. There were no warning lamps or dashboard messages prior to discovery, as frame corrosion is not monitored by vehicle systems. The defect was identified visually during state safety inspection. I am requesting that NHTSA investigate this defect pattern and consider a recall, as was ultimately ordered for the similar frame corrosion defect on Toyota Tacoma trucks.","products":[{"type":"Vehicle","productYear":"2018","productMake":"CHEVROLET","productModel":"SILVERADO 1500","manufacturer":"General Motors, LLC"}]}]}