{"count":1,"message":"Results returned successfully","results":[{"odiNumber":11737126,"manufacturer":"Tesla, Inc.","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"04/16/2026","dateComplaintFiled":"05/11/2026","vin":"7SAYGDEE9PA","components":"SUSPENSION","summary":"Vehicle brought to Tesla Service Plano TX for front-end rattle on bumpy roads at 49,951 miles. Technician found right front compliance arm split, left front compliance arm tearing, right front aft link starting to wear, left front aft link split at bushing, rear bolt for link loose, and opposite side nut separated from the subframe causing bolt to have zero tension. Tesla replaced entire front subframe assembly, both front lower lateral links, and both front lower compliance links under Basic Vehicle Limited Warranty. During the same visit, the technician performed a Vehicle Health Check (form SC-25-00-016 R2) and documented additional rear suspension defects: rear lower fore links have play and rear upper fore link bushings have excessive travel. Technician marked the suspension section as Repair/Replace. Service center declined warranty coverage on the rear, calling it normal wear despite the technician's findings. This is the second major warranty visit. At 14,928 miles in September 2024, Tesla Austin replaced the Power Conversion System, 16V Li-Ion battery, and pyrotechnic battery disconnect due to a loose harness connector causing vehicle shutdown warnings. Vehicle was manufactured at Tesla Gigafactory Austin TX. A separated subframe nut is a structural safety defect that could result in wheel alignment shift and loss of vehicle control. I drove this vehicle with my family including two children before the defect was discovered. Tesla Service Plano, service number XXX, service advisor Owen V [XXX]  INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)","products":[{"type":"Vehicle","productYear":"2023","productMake":"TESLA","productModel":"MODEL Y","manufacturer":"Tesla, Inc."}]}]}