{"count":1,"message":"Results returned successfully","results":[{"odiNumber":11764430,"manufacturer":"Ford Motor Company","crash":false,"fire":false,"numberOfInjuries":0,"numberOfDeaths":0,"dateOfIncident":"09/09/2026","dateComplaintFiled":"09/15/2026","vin":"1FMSK8DH6LG","components":"POWER TRAIN,ELECTRICAL SYSTEM,FORWARD COLLISION AVOIDANCE","summary":"I own a 2020 Ford Explorer XLT AWD, VIN 1FMSK8DH6LGA35229. While driving, my vehicle displayed “4WD Fault – Service Required” along with the powertrain wrench warning. I then became unable to select/change drive modes. Pre-Collision Assist became unavailable, I experienced Lane Keeping/Lane Assist problems, and additional stability/traction warnings appeared.  A professional diagnostic scan found AWD codes C0631:7E-68 and C0631:7F-6C related to the front axle disconnect actuator. The ABS module also stored U0102 (Lost Communication With Transfer Case Control Module) and U0155 (Lost Communication With Instrument Panel Cluster).  My mechanic diagnosed failure of the front axle disconnect actuator/intermediate-shaft system. The repair requires removal of the original disconnect system and installation of Ford’s revised intermediate shaft/axle components, replacement of the vent/breather hose, and AWD programming. I was quoted approximately $1,337. The mechanic will then determine whether the transfer case/AWD control module also requires replacement, which would cost approximately $828 additional.  Ford has issued TSB 25-2373, superseding TSB 23-2174, for certain 2020-2021 Explorer AWD vehicles. The bulletin specifically identifies C0631 and/or C00A6 and the front axle disconnect actuator/intermediate shaft and directs replacement with a revised intermediate shaft.  I am concerned this is a safety defect because the failure resulted in AWD/drive-mode malfunction while multiple driver-assistance systems became unavailable. I request that NHTSA investigate this known failure and determine whether a safety recall is warranted.","products":[{"type":"Vehicle","productYear":"2020","productMake":"FORD","productModel":"EXPLORER","manufacturer":"Ford Motor Company"}]}]}